Hearth and Home Technologies manual SL-550TRSI-AUE Service Parts List

Page 38

SL-550TRSI-AUE Service Parts List

IMPORTANT: When ordering, supply serial and model numbers to ensure correct service parts.

	ITEM	PARTS	PART NUMBER
	1	Valve NG	2098-130
	1	Valve LP	2098-131
		Valve LP	2098-131
	2	Orifice NG	582-840
	2	Orifice LP	582-057
		Orifice LP	582-057
	3	Flexible Gas Connector	530-302A
	4	Burner Assembly NG	2079-010
	4	Burner Assembly LP	2079-012
		Burner Assembly LP	2079-012
	5	Ignition Cable	2098-147
	6	Hood	SRV550-175
	7	Glass Door Assembly	GLA-550TRS
	8	Dress Guard	2079-040
	9	Top Louver	550-251A
	10	Lower Door	2079-041
	11	Grate	2021-007
	12	Base Refractory	550-117
	13	Blower Assembly 240V	100-505A
	14	Junction Box	2078-025
	15	Power Cord	546-251A
	16	Pilot Assembly NG	2098-050
	16	Pilot Assembly LP	2098-051
		Pilot Assembly LP	2098-051
	17	Switch Assembly	2098-145
	18	Interior Top Heat Shield	2079-109
	19	Gas Shutoff Assembly	2078-022
	20	Rheostat	491-510A
	21	Switch Sensor	046-530
	22	Log Set Assembly	LOGS-550TRSAUD
	23	Log #1	SRV550-715
	24	Log #2	SRV347-703
	25	Log #3	SRV349-704
	26	Log #4	SRV278-705
	27	Log #5	SRV540-704
	28	Log #6	SRV550-718
	29	Log #7	SRV484-703
	30	Log #8	SRV347-701
	31	Valve Plate Gasket	530-431
	32	Pilot Bracket	2079-104
	33	Valve Bracket	2089-120
	34	Control Cable	2098-143
	35	Module, Maxitrol	2098-142
	36	240V Adaptor	2098-144
	37	Burner Neck Gasket	2045-407
	38	Rheostat Knob	100-512
	39	Thermocouple Block	2098-146
	40	Block Control Wire	2098-148
		Glass Latch Assembly	386-122A
		Mineral Wool	050-721
		Mesh Assembly	561-330A
		Exhaust Resistor	347-299
		Accesssories
		Wall Switch Kit, Off White	WSK-21
		Wall Switch Kit, White	WSK-21W
		Conversion Kit NG	NGK-550I-AUE
		Conversion Kit LP	LPK-550I-AUE

38	Heat & Glo • SL-550TRSI-AUE • 2079-902 Rev. B • 7/06

Image 38

Contents Model SL-550TRSI-AUE Kensington Boulevard, Lakeville, MN 55044 USAHeat & Glo Quality Systems registered by SGS ICS Table of Contents Diagram of SL-550TRSI-AUE Rear Flue Installation InstructionsTop Flue Framing Dimensions IntroductionSpace heaters Identifying Flue Components Flue System ApprovalsModel Flue Termination Approvals DVP90ST Heat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/06 USE SL D-SERIES Vertical FlueingMaximum 10.97M USE DVP-SERIES Components onlyUSE SL D-SERIES Components Only Flueing with ONE 1 90 Elbow USE DVP-SERIES ComponentsFT. V M FT. HM Flueing with TWO 2 90 Elbows+ H FT. M Flueing with TWO 2 90 Elbows Flueing with Three 3 90 Elbows + H1 FT. MFlueing with Three 3 90 Elbows Installing Flue Components Nent and the Outer Heater Wrap Assembling Flue ComponentsInstall Support Brackets Continue Adding Flue ComponentsInstalling Support Brackets Hole and New Framing MembersFlue Termination Connecting the GAS Supply Gas Supply LineIgnition System Wiring Shock RiskBlower FAN Finishing CeilingPilot Assembly Installer TestingInstalling the Trim 3 4 5 6 7 Heat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/06 Heat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/06 Operating Trol Wiring System of this UnitOperating Instructions This Appliance MAY Exhibit a Slight Carbon DepositionSafety & Lighting Information Do not Connect 220/240 VAC to the Control ValveFAN Operation Servicing and MaintenanceGlass Door When IT is HOT Adjustments and Replacement Parts Removal of Components for ServiceParts Replacement Removal of Covers for ServicingMaintenance Tasks Doors Inspect Maintenance TasksTroubleshooting Electronic Ignition SystemPan beneath the burne Log set assembly SL-550TRSI-AUESL-550TRSI-AUE Service Parts List Heat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/06 Melbourne