Burnham MMII manual Burner and Flueway Cleaning

Page 25

Figure 25: Burner and Flueway Cleaning

25

Image 25

Contents 81404025R13-1/07 Price $3.00 MinutemanTable of Contents Dimensional Drawing Minimum Clearances to Combustible Surfaces Pre-InstallationIII. Water Piping and Trim II. Unpack BoilerDo not drop boiler. Do not bump boiler jacket against floor Page Internal Water Piping System Diagram Domestic Hot Water Ratings IV. Domestic Hot Water Performance and PipingRated Input Gas PipingSpeciﬁc Gravity Correction Factors Fitting Equivalent LengthsComponent VI. Venting / Air Intake PipingGeneral Guidelines Vent/Air Intake LengthBurnham Vent System Components Install Vent ConnectorInstall Vent Pipe, Burnham Gasket-Less Vent System Install Vent Pipe, GeneralInstall Vent Pipe, Burnham Gasketed Vent System Burnham Gasketed Vent Joint Detail Horizontal Through Wall Vent InstallationRecommended Horizontal Vent Installation Horizontal Vent Pipe Wall Penetration Vertical Through Roof Vent InstallationInstall Air Intake Pipe Vertical Vent InstallationVII. Electrical Wiring DiagramVIII. System Start-up Do not install an automatic fill valve with this boilerPrepare to check operation Operating Instructions Check Boiler High Limit Adjust gas input rate to boilerGas Flow Rate in Cubic Feet per Hour IX. Service Lubrication Main Burners and Combustion ChamberBurner and Flueway Cleaning Pilot Burner Location Differential Pressure Switch SettingsAvoid Breathing Fiber Particulates and Dust Page Page Heat Exchanger Assembly Repair PartsCanopy/Blower Assembly Cerafelt Gasketing not depictedPage Page Base Assembly Page Page Jacket Assembly Domestic Water Tank Assembly Miscellaneous Trim and Controls Air Intake Terminal Vent Accessory CartonLimited Warranty