Argosy Research H-125 Series owner manual Relay troubleshooting, Problem Cause

Page 21

relay troubleshooting

PROBLEM			CAUSE
20.	Relay does not energize
A.	Relay driver programmed on "Time"	A.	Programmed incorrectly
		B. Faulty wire connections between
			PC board and relay
		C.	Defective PC Board
		D. Defective relay, See figure below

B.Relay driver programmed on "Gallons" A. Programmed incorrectly

B.Defective PC Board

C.Defective relay, See figure below

D.Faulty meter connection

E.Faulty wire connections between PC board and relay

CORRECTION

A.Reprogram, see page 11

B.Check and repair wire connections

C.Replace PC Board

D.Replace Relay

A.Reprogram, see page 11

B.Replace PC Board

C.Replace Relay

D.Repair or replace meter assembly

E.Check and repair wire connections

21

Image 21

Contents With HP Electronics Table of Contents On TimeRelay Job Specification SheetOperating Conditions Soft Water BasicsBypass valve Operation Pre-Installation Check ListInstallation Instructions 650 User displays/settings635 Programming635PM Installer DISPLAYS/SETTINGS20 GR SET Time of DAYSoftener setup Cycle time adjustments800 MIN SET 12000 MIN6000 MIN MIN300 MIN 001 MINSET Regengal Service ReminderDiagnostics Reset Diagnostic Values Hold342 GAL Valve History 175 x1KBrine Reclaim Cycle Sequence800MIN EnabledOFF Water Softener Draining Procedure Water Softener DisinfectionMiscellaneous Cause Correction Trouble ShootingTrouble Shooting Problem Cause Relay troubleshootingDescription Qty H125 conditioner & salt keeper assembliesTank Assy Mineral Tank Distributor AssyDrawing no Order no Description Quantity Front Cover and Drive AssemblyInjector CAP, Injector SCREEN, INJECTOR, Plug and O-RING Spacer Stack AssemblyProper flow Drain line Drain line 3/4Bypass valve Water meter and meter plugInstallation fitting assemblies Wrench Flow Diagrams Service and Backwash Flow Diagrams Downflow Flow Diagrams Rinse and Fill Factory Regeneration Settings H125 SpecificationsProgramming options General specificationsResults Reserve capacity estimate based on history of water usageService Instructions Compliance Table Spacer Stack AssemblyRefill Flow Control Assembly or Refill Port Plug Page Page H125 Series Water Softeners Limited warranty