Frymaster 8196203 manual See next section for Drain

Page 55

8.3Drain System Components

8.3.1 Drain Tube Sections and Associated Parts

1

See next section for Drain

 

Valve Detail

 

7

 

8

 

6

 

7

 

6

 

1

 

5

 

2

 

3

 

2

 

3

 

4

 

4

8-6

Image 55
Contents Navy Surface Ship Electric Fryers Hour Service Hotline NOVPage Canada Navy Surface Ship Electric Fryers Navy Surface Ship Electric Fryers Introduction Safety InformationGeneral Service Information Shipping Damage Claim ProcedureController Information Introduction Navy Surface Ship Electric Fryers Installation InstructionsPage Power Requirements Single Fryer with Filter Dimensions and WeightsSingle Fryer non-filter Fryer Battery62.55 Navy Surface Ship Electric Fryers Operating Instructions Equipment Setup and Shutdown ProceduresOperation of the Solid-State Analog Controller ShutdownController Operating Procedure Page Navy Surface Ship Electric Fryers Filtration Instructions Open drain valve by rotating 90º Filter Pump Reset Switch Page Navy Surface Ship Electric Fryers Preventive Maintenance Page Check Calibration of Temperature Control Knob Monthly Clean Detachable Parts and Accessories WeeklyFryer Annual/Periodic System InspectionBuilt-In Filtration System Page Navy Surface Ship Electric Fryers Operator Troubleshooting Troubleshooting Control and Heating Problems Problem Probable Causes Corrective ActionProblem Filtration Problems Error Messages and Display ProblemsProblem Probable Causes Replacing a Controller Navy Surface Ship Electric Fryers Service ProceduresReplacing Component Box Components Replacing a High-Limit Thermostat Replacing a Temperature Probe Replacing a Heating Element Position Replacing Contactor Box Components Replacing a Frypot Page Sediment Particle Oil Flow Up for reverse Down for forward Disconnect flexlines indicated by the arrows Page Replacing the Filter Transformer or Filter Relay Diagnostic LED Legend Interface Board Diagnostic ChartProbe Resistance Chart Probe Resistance ChartRefer to page 2-2 for power requirements Refer to page 2-2 for power requirements Refer to page 2-2 for power requirements Wiring Diagram, Wiring Harness Page Accessories Navy Surface Ship Electric Fryers Parts ListPage Two and Three Station Fryers Cabinets, Bases, Braces, and Associated Parts Cabinet Bases, Braces, and Associated Parts See next section for Drain PART# Drain Tube Section and Associated PartsNut, ½-13 2-Way Hex Lock PART# Page Item PART# Relays are not replaceable Electronics and Wiring Components Component Boxes807-3575 Not illustrated Contactor Boxes Contactor Boxes Heating Element Assembly and Associated Parts Heating Element Assembly and Associated Parts Controller WiringContactor Box Wiring Assembly 12-Pin Full-Vat C-1 Contactor Box Wiring Assemblies 6-Pin Left Element106-5750 106-5935 Interface Board to Controller Wiring Harness 15-Pin Filtration System Components 1 FPH17 Filtration Components Assembly, Filter Pan Single includes pan and lid Multiple Battery Filtration System Components Multiple Battery Filtration System Components Frypot Assembly and Thermostat Oil Return System Components Component Component Wiring Connectors, Pin Terminals and Power CordsFasteners This page Intentionally Left Blank Service Hotline