Ice-O-Matic
GEM0650R, GEM1256R, GEM0956R
installation manual
GEM0650/0956R
Specifications
Install
Refrigeration Schematic
Warranty
Maintenance
Symptom
Control System Diagnostics
Freight Claim Procedure
Sanitizing and Cleaning
Low Condensing Temperature
Page 8
GEM0650/0956/1256 Remote
For The Installer
GEM0650/0956R
Page 2
Page 7
Page 9
Image 8
Page 7
Page 9
Contents
Pearl Ice Series
By Ice-O-Matic
Page
Introduction
Keep this manual for future reference
Table Of Contents
Freight Claim Procedure
Inspect Promptly
Visible Loss or Damage
Concealed Loss or Damage
Warranty
Governing LAW
For the Installer
GEM0650/0956R
GEM1256R
Ice Machine Specifications
Bin Application
Location
Storage Bin
Ice machine
Water Limitations
ERC Dimensions Inches GRC1001 GRC1061 GCR2061
Remote Condenser
Pearl Ice Number
Line Sets
Calculation Example
Remote Condenser Location
Calculation Formula
Precharged Line Set Routing
Remote Condenser Location
Roof Attachment
Typical Installation
Coupling Instructions Initial Connections
Final Connections
Drains Ice Machine
For the Plumber
Water Inlet
For the Electrician
Completed Installation
Final Check List
There are no adjustments to make, so replace the panels
Start Up
Pre-Start Inspection
Start Up
Component Description
Control Board
GEM0650/0956/1256 Remote
Electrical Sequence
Operation Water
Water
Water Level
Water System
Refrigeration Schematic
Operation Refrigeration
Low Condensing Temperature
Pump Down
Operation Performance
Sanitizing and Cleaning
Condenser Maintenance
Brush in direction of fins
Bearing Maintenance
Bearing Maintenance
Water Sensor
Sensor Maintenance
Bin Control Sensor
Auger Maintenance
Auger
Service Diagnosis
Symptom Possible Cause Probable Correction
Symptom
Control System Diagnostics
High pressure cut out check
Bin Controls Ice Level Sensors
Water Reservoir, Bin Control
Water Reservoir
To Remove the Breaker Bearing Assembly
Bearing and Breaker
Auger
To Remove the Auger
Water Seal
To Remove the Water Seal
Removal of the Water Seal To Replace the Water Seal
Replacing the Water Seal
To Reassemble the Evaporator and Auger
Evaporator
To Replace the Evaporator
To Remove and Repair the Gear Motor Assembly
Gear Motor
To Check the Gear Motor
To Inspect the Gear Motor
To Remove the Condenser Fan Motor Assembly
Fan Blade and Motor
Refrigeration Service
Charging Procedure
GEM0650R Wiring Diagram
Wiring Diagram GEM0650R
GEM0956R Wiring Diagram
Wiring Diagram GEM0956R
GEM1256R Wiring Diagram
Wiring Diagram GEM1256R
Service History
What to Do Before Calling for Service
Related pages
Troubleshooting for Toshiba 7FM03281000
Specifications for Accton Technology EN2218
Understanding Error Messages for Samsung WF8528N7W/YLE
Digital Input Diagram for Vivotek IP8130
HOW to Obtain Service What is not Covered for RIDGID R5013
To Install And Remove The Spur Center for Harbor Freight Tools 65345
Parts List for Huffy AR64S-H
Language code list for Sansui HDLCDVD265
Add a control resistor as shown in the following diagram for Omron FQM1-MMP21
Specifications for RCA PRO846
Top
Page
Image
Contents