Vulcan-Hart VCE6H ML-126177 manual Drain Grating

Page 33

Complete Cleaning (continued)

The interior glass door (Fig. 10) is independently hinged to allow both sides of the glass doors to be cleaned. With the oven door open, pull the interior glass door away from the exterior oven door. The snap-release fasteners should allow the interior glass door to swing free. All four sides of the glass can be cleaned using a cloth and glass cleaner or warm soapy water and a clear water rinse. The area between, behind, and around the surfaces of the upper and lower hinges can be cleaned by holding both ends of a moist soapy cleaning cloth folded in a three inch wide strip and swabbing up and down; rinse and dry with clean wet or dry cloth in the same manner. When glass is clean, push the interior glass door against the exterior oven door and the snap-release fasteners should re-fasten the interior glass door to the exterior glass door so it operates as one door.

Wipe surfaces which touch the door gasket with a cloth or sponge and warm soapy water, rinse with warm clear water, and wipe with a dry cloth. CAUTION: Do not allow the door gasket to come in contact with food oils, petroleum solvents, lubricants, or caustic cleaners.

For 6 and 10 level ovens, remove the condensate gutter (Fig. 10) by removing the two thumb screws that attach it to the bottom of the inside of the door frame. For 20 level ovens, the three segment condensate gutter may be removed for cleaning. Save the screws. Wash and rinse the condensate gutter in a sink with warm soapy water and a clear water rinse, and dry with a clean dry cloth. To reinstall condensate gutter: Reverse the removal procedure, align screw holes and tighten screws.

Keep the cooking compartment drain (Fig. 10) working freely. After cooking grease producing foods, operate the oven with the compartment empty for 30 minutes at the end of the day, or slowly pour 1/2 gallon of warm soapy water down the drain, followed by 1/2 gallon of warm clear water. The drain grating may be removed for cleaning; replace it in its original position when done.

Leave the door slightly open when the oven is not in use to allow the inside to dry out.

Upper Hinge

Interior Glass Door

Upper Snap Fastener

Door Gasket

 

 

Lower Hinge

 

 

 

 

Condensate Gutter

 

 

 

Drain Grating

(2 screws)

 

 

 

 

 

Lower Snap Fastener

PL-41379-1

Fig. 10

– 33 –

Page 32 Page 34
Image 33
Page 32 Page 34
Contents Installation Table of Contents Unpacking LocationStacking Kits Legs or Casters Available Installation AccessoriesLeveling Condensate Drip PANWater Requirements Plumbing ConnectionsWater Requirements Water Supply Connections FigElectrical Data Electrical ConnectionVent Hood Before First USEGrease Filter Door Opening and ClosingLoading the Oven Unloading the Oven BuzzerCool Down Programmable Controls MinOFF Cooking ModeDown Program NumberUsing the Temperature Probe ProbeCooking with the Probe Temperature Probe Applications ProductEntering a Cooking Program Programming Memory Recalling a Program from Memory 0 F Fish Convection Baking Applications HOT AIR Mode2F 1 Vegetables Steaming Applications5 F Beef Combi ApplicationsCook and Hold 300 F Cook and Hold ApplicationsPhase Example ProgramSave Menu Card Mode Finish Oven ControlTime Temp Humidifier Deluxe Manual Control Selector Switch OFFEntering a Manual Cooking Operation Deluxe Control Cooking Time Standard Manual ControlEntering a Manual Cooking Operation Standard Control Cleaning Daily CleaningComplete Cleaning Drain Grating Clean Cycle Deliming Tank Volume and Chemical Requirements Clean Cycle Deliming ProcedurePage Configuration Mode Programmable Control Elevation FAN Motor Coefficients TableConfiguration Mode Manual Control Standard or Deluxe Number Minimum Value Maximum Value Service and Parts Information Service Adjustments
Top Page Image Contents