Cornelius 2232MS service manual Sealing Ends of Floor Chase if Applicable

Page 9

A.Connect bulk syrup tank into system.

B.Connect three other flavors syrup tanks into syrup systems.

18.Installation Using Optional Syrup Tank Kit (P/N 0673) (see Figure 7.)

A.Connect four syrup tanks into syrup systems.

B.Connect three other flavors syrup tanks into syrup systems.

19.Operate all Dispenser(s) dispensing valves to bleed all air from syrup systems.

CHECKING ENTIRE SYSTEM FOR SYRUP, CO2 GAS, AND PLAIN AND CARBONATED WATER LEAKS

Check entire system for syrup, CO2 gas, and plain and carbonated water leaks and repair if evident.

SEALING ENDS OF FLOOR CHASE (IF APPLICABLE)

1.Pack ends of floor chase with paper to within approximately six–inches from the top.

2.Seal ends of floor chase with plaster of paris which may be purchased at a local building materials store.

8	0713

Image 9

Contents This Document Contains Important Information Manfactured IMI Cornelius INC ANOKA, MinnesotaGeneral Description General Warranty PolicyTerms and Conditions Ordering InformationComplete Service Distribution CentersIMI Cornelius Inc Specifications Installing POST-MIX Dispensers InstallationInstalling Beverage Control Panel Assembly Loose-Shipped Parts Name Qty Make Sure ALL Lines are Labeled for Identification Fastening Beverage Control Panel Assembly to WallNo TAG Preparation for Operation0713 Sealing Ends of Floor Chase if Applicable Standard Beverage Control Panel ASS’Y Water Pressure Pressure Switch Check Water Valve Surge Tank Water Pump Pressure Switch Check Check Valve Water Pump PRE Filet BUN CO2/AIR and Syrup Systems Flow Diagram Sprite Diet Orange Coke Conn NBR Description QTY Sprite Diet Orange Coke Bulk Tank Conn NBR Description QTY Sprite Diet Orange Syrup Bulk Tank Conn NBR Description QTY Diet sprite coke Conn NBR Description QTY POST-MIX Dispenser Service and Maintenance Service and MaintenanceBeverage Control Panel Assembly Service Maintenance Hazard in the water systemPressure Switch Liquid Check Valve Water Pump Motor Always Install NEW Ball Seat Quadding P/NSwitch Bars Cleaning Optional Syrup Lines Strainers see FigureReplenishing CO2 Supply Sanitizing Syrup SystemsReplenishing Syrup Supply Cause serious personal injurySyrup Flavor Change Troubleshooting Water Inlet Pressure CYCLES’’ CON’TGauge Reads TOO LOW Gauge Reads TOO HighAIR Compressor ‘SHORT Not Operate CON’TDispensed Drinks have ‘OFF’’ TasteWiring Diagram Carbonator Instructions for Crimping Tube Clamps Beverage Control Panel ASS’Y Beverage Control Panel ASS’Y CO2 Regulator ASS’Y P/N CO2 Check Valve ASS’Y P/N Name No. Part No NameCO2 Regulator ASS’Y Check Valve and Manifold ASS’Y P/N Large Reserve Carbonator Large Reserve Carbonator Water Manifold ASS’Y P/N Pump and Motor ASS’Y Regulator ASS’Y, HI-PRESSURE P/N Warranty