Multiquip DCA-400SSK operation manual Rules for Safe Operation, Radiator

Page 7

RULES FOR SAFE OPERATION

CAUTION:CAUTION:

DO NOT touch or open any of the below mentioned components while the generator is running. Always allow sufficient time for the engine and generator to cool before performing maintenance.

NEVER touch output terminals during operation. This is extremely dangerous. Always stop the machine when contact with the output terminals.

CAUTION:

Backfeed to a utility system can cause electrocution and/ or property damage. Do not connect to any building's electrical system except through an approved device or after building main switch is opened.

Radiator

1.Radiator Cap - Removing the radiator cap while the engine is hot, will result in high pressurized, boiling water to spew out of the radiator, causing severe scalding to any persons in the general area of the generator.

2.Coolant Drain Plug - Removing the coolant drain plug while the engine is hot will result in hot coolant to flow out of the coolant drain plug, therefore causing severe scalding to any persons in the general area of the generator.

3.Engine Oil Drain Plug - Removing the engine oil drain plug while the engine is hot will result in hot oil to flow out of the oil drain plug, therefore causing severe scalding to any persons in the general area of the generator.

CAUTION:

Never use damaged or worn cables when connecting power tools or equipment to the generator. Make sure power connecting cables are securely connected to the generator’s output terminals, insufficient tightening of the terminal connections may cause damage to the generator and electrical shock.

DCA-400SSK — PARTS AND OPERATION MANUAL (STD)— REV. #3 (09/17/01) — PAGE 7

Image 7
Contents MQ Power DCA-400SSK DCA-400SSK2 Whisperwatttm Generator Page Heres HOW to GET Help Table of Contents Parts Ordering Procedures Earn Extra Discounts when You order by FAXRules for Safe Operation High Temperatures AllowRadiator Rules for Safe OperationLoading and Unloading Crane BatteryTransporting Maintenance SafetyEmergencies DCA-400SSK -TOWING Towing Safety PrecautionsExplanation of Chart DCA-400SSK TRAILER-SAFETY GuidelinesWidth DCA-400SSK -TRAILER-SPECIFICATIONSModel Coupler Tires Wheels Axle Hubs Suspension Electrical Brakes Electric Brake AdjustmentElectric Brakes Hydraulic/Air/Surge Brakes DCA-400SSK -TRAILER Safety GuidelinesTire Wear/Inflation Tires/Wheels/Lug NutsSuspension Lug Nut Torque Requirements Torque Ft.-LbsDCA-400SSK -TRAILER-WIRING Diagram Symptom Possible Cause Solution DCA-400SSK -TRAILER-BRAKETROUBLESHOOTINGDCA-400SSK -TRAILER-BRAKETROUBLESHOOTING Machine Safety Decals DCA-400SSK Operation and Safety DecalsDCA-400SSK Operation and Safety Decals DCA-400SSK Specifications DCA-400SSK General Information JacketWater Heater Optional Battery ChargerEngine Electronic Governor SystemMajor Components DCA-400SSK Major ComponentsPage Dimensions Dry weight 4270kg 9413.64lb Wet weight 4800kg 10582.08 lbDCA-400SSK Dimensions Front and Rear Control Panel DCA-400SSK Control PanelPilot Lamp Indicates that the generator is working properly DCA-400SSK Control PanelDCA-400SSK Engine Operating Panel DCA-400SSK Engine Operating Panel Ignition Switch up to S/N3696509DCA-400SSK Outputterminal Panel Overview DCA-400SSK Outputterminal Panel Overview Over Current Relay Output Terminal Panel Available VoltagesMaximum Amps DCA-400SSK Outputterminal Panel Overview How to read the output terminal gaugesVoltage Change-over Board Single Phase, 240 VoltPhase, 240 Volt Single Phase, 139 VoltPhase, 480 Volt Single Phase, 480 VoltSingle Phase, 277 Volt Outdoor Installation DCA-400SSK InstallationMounting Typical Generator Grounding Application DCA-400SSK InstallationGeneral Inspection Prior to Operation DCA-400SSK PRE-SETUPExtension Cable Fuel Lubrication OilCoolant Fan Belt Tension Cleaning the RadiatorAir Cleaner Operation in Freezing WeatherWiring Battery Cable InstallationPiping and Hose Connection Three Phase Load Single Phase LoadBefore Starting Generator and Control Panel Before Starting EngineDCA-400SSK Generator START-UP Procedure KEY Switch Engine Ignition Switch Ammeter Load Auto Start-up Manual Start-upEngine Shutdown DCA-400SSK Generator Shutdown ProcedureEmergency Stop Page DCA-400SSK Maintenance Changing Oil Check Electric Heater If equippedReplacing fuel filter Greasing Cleaning breather elementGenerator Storage Inspection / Maintenance DCA-400SSK Generator Wiring Diagram Page DCA-400SSK Engine Wiring Diagram KEY Switch DCA-400SSK Engine Wiring Diagram Controller DCA-400SSK -TROUBLESHOOTING Engine DCA-400SSK -TROUBLESHOOTING Engine Generator Troubleshooting DCA-400SSK -TROUBLESHOOTING GENERATOR/ENGINEDCA-400SSK -TROUBLESHOOTING Engine Controller Items Found In the Items Number Column Explanation of Code in Remarks ColumnQty Description DCA-400SSK Suggested Spare PartsDCA-400SSK Generator Assy Part Name QTY DCA-400SSK Generator Assy COVER, Bearing DCA-400SSK Control BOX Assy Part Name QTY Remarks DCA-400SSK Control BOX AssyDCA-400SSK Control BOX Assy RA20A2SE102BJ 2W 1K OHM DCA-400SSK Engine & Radiator Assy Dust Sensor DCA-400SSK Engine & Radiator Assy DCA-400SSK Engine & Radiator Assy UP to S/N 3701677~ DCA-400SSKENGINE Operating Panel AssyDCA-400SSK Engine Operating Panel Assy DCA-400SSK Outputterminal Assy DCA-400SSK Output Terminal Assy DCA-400SSK Battery Assy Battery DCA-400SSK Actuator Assy DYNC11020300024 DCA-400SSK Muffler Assy Muffler DCA-400SSK Fuel Tank Assy Fuel Tank DCA-400SSK Enclosure #1 Assy Floor Panel DCA-400SSK Enclosure #1 Assy Filler Bracket Enclosure #2 Assy DCA-400SSK Enclosure #2 AssyRear Frame DCA-400SSK Enclosure #2 Assy COVER, Roof Panel Enclosure #3 Assy DCA-400SSK Enclosure #3 AssySide Panel DCA-400SSK Enclosure #3 Assy 0845046904 DCA-400SSK Rubber Seal Assy Rubber Seal Assy DCA-400SSK OIL Piping Assy Pump N3701677~ DCA-400SSK Name Plate and DecalsControl BOX Group Bonnet Group Battery Group Engine and Radiator Group Output Terminal Group DCA-400SSK Name Plate and DecalsEffective July 1 Page Mail mq@multiquip.com WWW multiquip.com