Steam Trim | Burnham IN10 specs

	Key	Description	Part No.	Quantity
	No.	Description	Part No.	Quantity
	No.
	Steam Trim

	7A	Safety Valve, 3/4 NPT, 15 psi, Conbraco 13-511-08	81660530	1

	7B	Elbow, 3/4 NPT	806601502	2

	7C	Nipple, 3/4 NPT x 3"	806600002	2

		Low Water Cutoff, McDonnell & Miller PS-802-24 (Probe Included)	80160720
	8A	Low Water Cutoff, Hydrolevel CG400-2090 (Less Probe - See Key No. 8B)	80160725	1
		Low Water Cutoff, McDonnell & Miller 67-BC-1 (Float Type)	80160517
	8B	Probe for CG400	80160629	1

	9	Gauge Glass, Extended Shank (with Probe LWCO Only)	8056128	1

		Gauge Glass, Standard Shank (with Float LWCO Only)	8056020
		Gauge Glass, Standard Shank (with Float LWCO Only)	8056020

	10A	Limit, Honeywell L404F1367	80160369	1

	10B	Syphon, 1/4 NPT x 90°	806603010	1

	10C	Bushing, 3/4 NPT x 1/4 NPT	806600508	1
	10D	Syphon, 1/4 NPT x 180°	806603030	1

	11A	Pressure Gauge	8056010	1

	11B	Drain Valve, Conbraco 31-612-02	806603012	1

	11C	Bushing, 2 NPT x 3/4 NPT	806600515	1

83

Image 83

Burnham IN10 manual Steam Trim

Contents

8141049R26-10/08 Price $5.00 IndependencePage Page Dimensional Drawing Table of Contents Probe L.W.C.O Float L.W.C.O Tankless Heater Pre-Installation Clearance to Combustible Materials Install assembled cast iron sections on base assembly II. Knocked-Down Boiler AssemblyInstall Base-Burner-Manifold Assembly Canopy Gasket Installation Install Canopy Combustion Chamber Intermittent Ignition EI Install Ignition Module Install Blocked Vent Switch with sheet metal screws Steam Boiler with Probe Low Water Cutoff III. Semi-Pak Boiler AssemblyInstall Trim and Controls Remove Crate Water Boiler Junction Box and Mounting Bracket Assembly Remove Jacket Front Panel. See Figure IV. Packaged Boiler AssemblyInstall Jacket Front Panel Piping and Trim Page Recommended Water Piping for Circulator Zoned Heating System Recommended Water Piping for Zone Valve Zoned Heating System Recommended Piping for Indirect Water Heater Page Connect boiler gas valve to gas supply system VI. Gas PipingRated Input Specific Gravity Correction Factors for Natural Gas Fitting Equivalent Lengths Boiler Equipped With Vent Damper VII. Venting If an Existing Boiler is Removed Typical Vent Installation VIII. Electrical Wire Vent Damper if used Alliance Indirect Water Heater if used Thermostat Heat Anticipator Settings Vent Damper Harness to Limit This page Left Intentionally Blank Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Follow Lighting or Operating Instructions IX. System Start-upFill boiler with water Prepare to check operationPage Page Page Page Ignition Module Terminal Cross-Reference Ignition Module Wiring Ladder Diagram Terminal Designation OFF Green LED Status Codes Pilot Burner Flame, Honeywell Q350 Check Limit Adjust gas input rate to boiler. Natural GasCheck low water cutoff steam only Do not drain below gauge glass Input Rate Adjust gas input rate to boiler. LP/PropanePage Page Maintenance of Low Water Cutoff Service Instructions Clean Boiler Flueways Boiler Flueway Cleaning Tankless Heater Pilot Burner Location Model No Gallons Per Month Year Excessive Make-Up Water Honeywell Electronic Ignition Trouble Shooting Guide Honeywell Hot Surface to Pilot Trouble Shooting Guide Avoid Breathing Fiber Particulates and Dust Service Record XI. Repair Parts Section Assembly Canopy and Draft Hood Canopy/Draft Hood Parts Base Tray Base Assembly Burner Tray 1 Inch Main Burners Manifold and 1 Main Burners Manifold and Main Burners 1 Inch Main Burners Only Volt Continuous Ignition Standing Pilot Natural Gas Manifold and 40mm Main BurnersManifold and Main Burners 40MM Main Burners only Intermittent Ignition Only Natural Gas, High Altitude 2000-4500 Ft. Canada Only LP Gas, High Altitude 2000-5000 Ft. USA OnlyNatural Gas, High Altitude 5000-9000 Ft. USA Only LP Gas, High Altitude 5000-9000 Ft. USA Only Pilot Burner, Honeywell Q350A1321 Pilot Burner, Honeywell Q348A1002 Page Jacket Assembly Front Top Panel Jacket Assembly Refer to Figure on Steam Trim Page Water Trim Quantity This page Left Blank Intentionally Page Ignition Module Intermittent Ignition Only Flame Rollout SwitchBlocked Vent Switch Transformer Steam and Gravity Water Only Lwco Location Wiring of Typical LwcoXII. Low Water Cut Off Lwco Limited Warranty Limited Warranty