J6J5, J1 J8, AL1 | Carrier 50RTP03-20 manual

LEGEND

CR — Control Relay

LWT — Leaving Water Temperature Sensor SAT — Supply Air Temperature Sensor SPT — Space Temperature Sensor

NOTE: Reversing valve is on in Cooling mode.

PWR

J6J5

PREMIER

LINK

PWR

HS1/EXH/RVS

CR

CMP1

FAN

J1 J8

J4

COMPLETE

C

CONTROL

Y

W

CR

O

G

R

C

AL1

AL2

A

S	S	L	CMPSAFE
S	S	L
P	A	W
T	T	T

Fig. 12 — Premierlink™ Controller Applications Wiring with Complete C Control

		PREMIER
		LINK
		PWR
		HS2
		HS1
LEGEND		CMP2
LWT — Leaving Water Temperature Sensor
SAT — Supply Air Temperature Sensor
SPT — Space Temperature Sensor		CMP1
NOTE: Reversing valve is on in Cooling
mode.
		FAN
		J8
	PWR	J1
J6	J5	J4

S	S	L	CMPSAFE
S	S	L
P	A	W
T	T	T

DELUXE

D

CONTROL

Y1

Y2

W1

O/W2

G

R

C

AL1

Fig. 13 — Premierlink Controller Applications Wiring with Deluxe D Control

30

Image 30

Carrier 50RTP03-20 specifications J6J5, J1 J8, AL1

Contents

Contents Safety Considerations Installation General Physical Data Aquazone 50RTP03-20 Units Dimensions Outside Air Water CondensateIn/Out FPT Drain 03,04 12.57 x In/Out FPT 18.95 x 11/4 10,12 11/2 50RTP14,20 Unit Dimensions 14,20 18.95 x Return Air Transition Supply Air Transition Exterior 78.875 82.25 21.00 25.00 19.00 82.875 76.875 27.00 86.25 Install Condensate Drain 50 RTP Connect Electrical Wiring Water Quality Guidelines Electrical Data FLA Hacr 50RTP03 Blower Performance Data 50RTP04 Blower Performance Data 50RTP05 Blower Performance Data 50RTP06 Blower Performance Data 50RTP08 Blower Performance Data 3800 39004000 50RTP10 Blower Performance Data 41004200 4500 43004400 4600 50RTP12 Blower Performance Data 50RTP14 Blower Performance Data 6200 6800 64006600 7000 50RTP20 Blower Performance Data 10,000 Rpm 940 956 976 996 1016 1036 1056 1076 1092 Turns Open ECR See legend and notes on 50RTP03-06 Units 50RTP08-20 Units Hpwr A50-8557 Typical Control Wiring with Deluxe D and LON Controller Sizes J6J5 J1 J8AL1 A50 Units with Deluxe D and Wshp Open Multiple Protocol Controls Wshp Open Control Reversing Valve Fan 24Vac Hot 24Vac Com Connect Low Voltage WiringCompressor-Stage Deluxe D PRE-START-UP Complete C Control Jumper Settings SeeDeluxe D Control Jumper Settings See Field Selectable Inputs DIP Switch Block S2 Accessory 1 Relay Options DIP Switch Block S2 Accessory 2 Relay Options START-UP Unit Start-Up Cooling ModeUnit Start-Up Heating Mode Operating Limits Unit Start-Up with Wshp Open Controls BACview6 Display InterfacePage Units with Aquazone Complete C Control Antifreeze Percentages by VolumeOperation Units with Aquazone Deluxe D ControlPage Auxiliary Modulating Hot Water/Steam Heating Reheat System Test Complete C Control LED Code Fault Descriptions Service Aquazone Deluxe D Control LED Indica Replacing the Wshp Open Controller’s Bat Refrigerant ChargingAir Coil Fan Motor Removal ’ to 4’ Troubleshooting FP1 and FP2 Thermistor Location Reduced or no water flow TroubleshootingAir temperature out of range Overcharged with refrigerant Unit Does Not Operate Status Appendix a Wshp Open Screen ConfigurationAlarm Status Sensor System Settings Appendix a Wshp Open Screen ConfigurationMaintenance Configuration Schedule Appendix a Wshp Screen Open Configuration ServiceTest Configuration Service Electronically Commutated Motor Alarm Page Page Copyright 2010 Carrier Corporation 50RTP START-UP Checklist II. START-UP Along Dotted Line Heating Cycle AnalysisCooling Cycle Analysis Catalog No Form 50RTP-1SI Pg CL-2 10A Replaces New