Manuals / Carrier / Household Appliance / Heat Pump

Carrier PCV015-060 specifications 8354

Models: PCV015-060

1 52

Page 17

	WSHP-OPEN
17	A50
	-8354
	LEGEND

BM	— Blower Motor
CO	— Condensate Overflow
LWT	— Leaving Water Temperature
N.C.	— Normally Closed
OAD	— Outside Air Damper
OCC	— Occupancy Input Contact
RH	— Relative Humidity
SAT	— Supply Air Temperature
SPT	— Space Temperature

Fig. 19 — Units with Deluxe D and WSHP Open Multiple Protocol Controls

Page 17

Image 17

Contents

SAFETY CONSIDERATIONS CONTENTSInstallation, Start-Up,and Service Instructions Deluxe D Control Accessory RelayGENERAL INSTALLATIONTable 1 - 50PCH,PCV Unit Physical Data 8412 Fig. 1 - 50PCH Unit DimensionsLEFT RETURN RIGHT RETURNUNIT HANGER ISOLATION DETAIL Fig. 2 - Typical Installation - 50PCH Unitsa50-8413 Fig. 3 - 50PCV Unit Dimensions50PCV Units Fig. 4 - Typical Vertical InstallationStep 4 - Mount the Unit Step 6 - Install Condensate DrainFactory Installed a50-8489Fig. 10 - Trap Condensate Drain a50-6261tfFig. 11 - Vertical Condensate Connection Table 2 — Metal Hose Minimum Bend RadiiFig. 12 - Supply/Return Hose Kit Step 8 - Wire Field Power SupplyComplete C Deluxe D Deluxe D a50-8493 Deluxe D a50-8440SAT - Supply Air Temperature LWT - Leaving Water TemperatureSPT - Space Temperature A50-83558354 8356 Page WSHP Open Inputs and Outputs Table Fig. 22 - WSHP Open Controla50-8162 Table 3 - 50PCH,PCV Unit Electrical DataAccessory Wiring Step 9 - Wire Field ControlsFig. 24 - Low Voltage Field Wiring Fig. 27 - AMV Valve WiringFig. 29 - Rnet Cable Wire Table 6 - Rnet Wiring SpecificationsTable 7 - Rnet Wiring Table 4 - Field-SuppliedSensors forFig. 30 — Blower Speed Selection PRE-START-UPTable 9 - 50PCV Blower Performance with Wet Coil Table 8 - 50PCV Blower Performance with HotWater Reheat HWR Option FIELD SELECTABLE INPUTS Operating Limits START-UPTable 12 - DIP Switch Block S2 Accessory 1 Relay OptionsTable 15 - Water Temperature Change Unit Start-UpCooling ModeTable 14 - Operating Limits - 50PCH,PCV Units Through Heat Exchanger115-125 114-124 Fig. 31 - BACview6 Display Interface Unit Start-UpHeating ModeUnit Start-Upwith WSHP Open Controls Table 23 - Coaxial Water Pressure Drop Units with Aquazone Complete C Control OPERATIONUnits with Aquazone Deluxe D Control Table 24 - Approximate Fluid Volume galUnits with WSHP Open Multiple Protocol Condensate overflow input is normal Damper control is configured for DCV Aquazone Deluxe D Control LED Indica COMPLETE C AND DELUXE D BOARD SYSTEM TESTStatus and Alarm Relay Operations Fault DescriptionsSERVICE Air Coil Fan Motor Removal Refrigerant ChargingFig. 32 - Gravity Flow Method Fig. 33 - Forced Circulation MethodReplacing the WSHP Open Controller’s Bat TROUBLESHOOTING Fig. 34 and 35, and TableFig. 34 - Thermistor Nominal Resistance a50-8163Table 29 - Troubleshooting Table 29 - Troubleshooting cont Outdoor Air Temperature APPENDIX A - WSHP OPEN SCREEN CONFIGURATIONSAT - Supply Air Temperature Space TemperatureOutdoor Air Temperature APPENDIX A - WSHP OPEN SCREEN CONFIGURATION contSAT - Supply Air Temperature Space TemperatureOutdoor Air Temperature APPENDIX A - WSHP OPEN SCREEN CONFIGURATION contSAT - Supply Air Temperature Space TemperatureOutdoor Air Temperature APPENDIX A - WSHP SCREEN OPEN CONFIGURATION contSAT - Supply Air Temperature Space TemperatureAPPENDIX A - WSHP SCREEN OPEN CONFIGURATION cont Outdoor Air Temperature APPENDIX A - WSHP SCREEN OPEN CONFIGURATION contSAT - Supply Air Temperature Space TemperaturePage Catalog No Copyright 2009 Carrier CorporationForm 50PC-1SI 7-09II.START-UP 50PCH,PCV START-UPCHECKLISTI.PRE-START-UP COOLING CYCLE ANALYSIS HEATING CYCLE ANALYSISFLOW RATE GPM TEMP. DIFF. DEG. F

-8354