Manuals / Carrier / Household Appliance / Heat Pump

Carrier PCV015-060 specifications 8356

Models: PCV015-060

1 52

Download 52 pages 34.31 Kb

Page 18

18	A50
	-8356

LEGEND

WSHP-OPEN

CO	— Condensate Overflow
LWT	— Leaving Water Temperature
N.C.	— Normally Closed
OAD	— Outside Air Damper
OCC	— Occupancy Input Contact
RH	— Relative Humidity
SAT	— Supply Air Temperature
SPT	— Space Temperature

Fig. 20 — Units with Complete C, ECM and WSHP Open Multiple Protocol Controls

Image 18

Carrier PCV015-060 specifications 8356

Contents

Installation, Start-Up,and Service Instructions CONTENTSSAFETY CONSIDERATIONS Deluxe D Control Accessory RelayINSTALLATION GENERALTable 1 - 50PCH,PCV Unit Physical Data LEFT RETURN Fig. 1 - 50PCH Unit Dimensions8412 RIGHT RETURNFig. 2 - Typical Installation - 50PCH Units UNIT HANGER ISOLATION DETAILFig. 3 - 50PCV Unit Dimensions a50-8413Fig. 4 - Typical Vertical Installation 50PCV UnitsFactory Installed Step 6 - Install Condensate DrainStep 4 - Mount the Unit a50-8489Fig. 11 - Vertical Condensate Connection a50-6261tfFig. 10 - Trap Condensate Drain Table 2 — Metal Hose Minimum Bend RadiiStep 8 - Wire Field Power Supply Fig. 12 - Supply/Return Hose KitComplete C Deluxe D Deluxe D a50-8493 a50-8440 Deluxe DSPT - Space Temperature LWT - Leaving Water TemperatureSAT - Supply Air Temperature A50-83558354 8356 Page Fig. 22 - WSHP Open Control WSHP Open Inputs and Outputs TableTable 3 - 50PCH,PCV Unit Electrical Data a50-8162Fig. 24 - Low Voltage Field Wiring Step 9 - Wire Field ControlsAccessory Wiring Fig. 27 - AMV Valve WiringTable 7 - Rnet Wiring Table 6 - Rnet Wiring SpecificationsFig. 29 - Rnet Cable Wire Table 4 - Field-SuppliedSensors forPRE-START-UP Fig. 30 — Blower Speed SelectionTable 8 - 50PCV Blower Performance with Hot Water Reheat HWR OptionTable 9 - 50PCV Blower Performance with Wet Coil FIELD SELECTABLE INPUTS Table 12 - DIP Switch Block S2 START-UPOperating Limits Accessory 1 Relay OptionsTable 14 - Operating Limits - 50PCH,PCV Units Unit Start-UpCooling ModeTable 15 - Water Temperature Change Through Heat Exchanger115-125 114-124 Unit Start-UpHeating Mode Unit Start-Upwith WSHP Open ControlsFig. 31 - BACview6 Display Interface Table 23 - Coaxial Water Pressure Drop Units with Aquazone Deluxe D Control OPERATIONUnits with Aquazone Complete C Control Table 24 - Approximate Fluid Volume galUnits with WSHP Open Multiple Protocol Condensate overflow input is normal Damper control is configured for DCV Status and Alarm Relay Operations COMPLETE C AND DELUXE D BOARD SYSTEM TESTAquazone Deluxe D Control LED Indica Fault DescriptionsSERVICE Fig. 32 - Gravity Flow Method Refrigerant ChargingAir Coil Fan Motor Removal Fig. 33 - Forced Circulation MethodFig. 34 - Thermistor Nominal Resistance TROUBLESHOOTING Fig. 34 and 35, and TableReplacing the WSHP Open Controller’s Bat a50-8163Table 29 - Troubleshooting Table 29 - Troubleshooting cont SAT - Supply Air Temperature APPENDIX A - WSHP OPEN SCREEN CONFIGURATIONOutdoor Air Temperature Space TemperatureSAT - Supply Air Temperature APPENDIX A - WSHP OPEN SCREEN CONFIGURATION contOutdoor Air Temperature Space TemperatureSAT - Supply Air Temperature APPENDIX A - WSHP OPEN SCREEN CONFIGURATION contOutdoor Air Temperature Space TemperatureSAT - Supply Air Temperature APPENDIX A - WSHP SCREEN OPEN CONFIGURATION contOutdoor Air Temperature Space TemperatureAPPENDIX A - WSHP SCREEN OPEN CONFIGURATION cont SAT - Supply Air Temperature APPENDIX A - WSHP SCREEN OPEN CONFIGURATION contOutdoor Air Temperature Space TemperaturePage Form 50PC-1SI Copyright 2009 Carrier CorporationCatalog No 7-0950PCH,PCV START-UPCHECKLIST I.PRE-START-UPII.START-UP FLOW RATE GPM HEATING CYCLE ANALYSISCOOLING CYCLE ANALYSIS TEMP. DIFF. DEG. F