Manuals / Carrier / Household Appliance / Heat Pump

Carrier PCV015-060 Copyright 2009 Carrier Corporation, Catalog No, Form 50PC-1SI, 7-09

Models: PCV015-060

1 52

Download 52 pages 34.31 Kb

Page 50

Copyright 2009 Carrier Corporation

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.

Catalog No. 04-53500049-01

Printed in U.S.A.

Form 50PC-1SI

Pg 50

7-09

Replaces: New

Image 50

Carrier PCV015-060 specifications Copyright 2009 Carrier Corporation, Catalog No, Form 50PC-1SI, 7-09, Replaces New

Contents

Installation, Start-Up,and Service Instructions CONTENTSSAFETY CONSIDERATIONS Deluxe D Control Accessory RelayINSTALLATION GENERALTable 1 - 50PCH,PCV Unit Physical Data LEFT RETURN Fig. 1 - 50PCH Unit Dimensions8412 RIGHT RETURNFig. 2 - Typical Installation - 50PCH Units UNIT HANGER ISOLATION DETAILFig. 3 - 50PCV Unit Dimensions a50-8413Fig. 4 - Typical Vertical Installation 50PCV UnitsFactory Installed Step 6 - Install Condensate DrainStep 4 - Mount the Unit a50-8489Fig. 11 - Vertical Condensate Connection a50-6261tfFig. 10 - Trap Condensate Drain Table 2 — Metal Hose Minimum Bend RadiiStep 8 - Wire Field Power Supply Fig. 12 - Supply/Return Hose KitComplete C Deluxe D Deluxe D a50-8493 a50-8440 Deluxe DSPT - Space Temperature LWT - Leaving Water TemperatureSAT - Supply Air Temperature A50-83558354 8356 Page Fig. 22 - WSHP Open Control WSHP Open Inputs and Outputs TableTable 3 - 50PCH,PCV Unit Electrical Data a50-8162Fig. 24 - Low Voltage Field Wiring Step 9 - Wire Field ControlsAccessory Wiring Fig. 27 - AMV Valve WiringTable 7 - Rnet Wiring Table 6 - Rnet Wiring SpecificationsFig. 29 - Rnet Cable Wire Table 4 - Field-SuppliedSensors forPRE-START-UP Fig. 30 — Blower Speed SelectionTable 9 - 50PCV Blower Performance with Wet Coil Table 8 - 50PCV Blower Performance with HotWater Reheat HWR Option FIELD SELECTABLE INPUTS Table 12 - DIP Switch Block S2 START-UPOperating Limits Accessory 1 Relay OptionsTable 14 - Operating Limits - 50PCH,PCV Units Unit Start-UpCooling ModeTable 15 - Water Temperature Change Through Heat Exchanger115-125 114-124 Fig. 31 - BACview6 Display Interface Unit Start-UpHeating ModeUnit Start-Upwith WSHP Open Controls Table 23 - Coaxial Water Pressure Drop Units with Aquazone Deluxe D Control OPERATIONUnits with Aquazone Complete C Control Table 24 - Approximate Fluid Volume galUnits with WSHP Open Multiple Protocol Condensate overflow input is normal Damper control is configured for DCV Status and Alarm Relay Operations COMPLETE C AND DELUXE D BOARD SYSTEM TESTAquazone Deluxe D Control LED Indica Fault DescriptionsSERVICE Fig. 32 - Gravity Flow Method Refrigerant ChargingAir Coil Fan Motor Removal Fig. 33 - Forced Circulation MethodFig. 34 - Thermistor Nominal Resistance TROUBLESHOOTING Fig. 34 and 35, and TableReplacing the WSHP Open Controller’s Bat a50-8163Table 29 - Troubleshooting Table 29 - Troubleshooting cont SAT - Supply Air Temperature APPENDIX A - WSHP OPEN SCREEN CONFIGURATIONOutdoor Air Temperature Space TemperatureSAT - Supply Air Temperature APPENDIX A - WSHP OPEN SCREEN CONFIGURATION contOutdoor Air Temperature Space TemperatureSAT - Supply Air Temperature APPENDIX A - WSHP OPEN SCREEN CONFIGURATION contOutdoor Air Temperature Space TemperatureSAT - Supply Air Temperature APPENDIX A - WSHP SCREEN OPEN CONFIGURATION contOutdoor Air Temperature Space TemperatureAPPENDIX A - WSHP SCREEN OPEN CONFIGURATION cont SAT - Supply Air Temperature APPENDIX A - WSHP SCREEN OPEN CONFIGURATION contOutdoor Air Temperature Space TemperaturePage Form 50PC-1SI Copyright 2009 Carrier CorporationCatalog No 7-09II.START-UP 50PCH,PCV START-UPCHECKLISTI.PRE-START-UP FLOW RATE GPM HEATING CYCLE ANALYSISCOOLING CYCLE ANALYSIS TEMP. DIFF. DEG. F