Manuals / Carrier / Household Appliance / Heat Pump

Carrier PCV015-060 specifications

Models: PCV015-060

1 52

Download 52 pages 34.31 Kb

Page 19

Image 19

LEGEND

WSHP-OPEN

CO	— Condensate Overflow
LWT	— Leaving Water Temperature
N.C.	— Normally Closed
OAD	— Outside Air Damper
OCC	— Occupancy Input Contact
RH	— Relative Humidity
SAT	— Supply Air Temperature
SPT	— Space Temperature

Fig. 21 — Units with Deluxe D, ECM and WSHP Open Multiple Protocol Controls

Page 19

Image 19

Contents

Deluxe D Control Accessory Relay CONTENTSSAFETY CONSIDERATIONS Installation, Start-Up,and Service InstructionsGENERAL INSTALLATIONTable 1 - 50PCH,PCV Unit Physical Data RIGHT RETURN Fig. 1 - 50PCH Unit Dimensions8412 LEFT RETURNUNIT HANGER ISOLATION DETAIL Fig. 2 - Typical Installation - 50PCH Unitsa50-8413 Fig. 3 - 50PCV Unit Dimensions50PCV Units Fig. 4 - Typical Vertical Installationa50-8489 Step 6 - Install Condensate DrainStep 4 - Mount the Unit Factory InstalledTable 2 — Metal Hose Minimum Bend Radii a50-6261tfFig. 10 - Trap Condensate Drain Fig. 11 - Vertical Condensate ConnectionFig. 12 - Supply/Return Hose Kit Step 8 - Wire Field Power SupplyComplete C Deluxe D Deluxe D a50-8493 Deluxe D a50-8440A50-8355 LWT - Leaving Water TemperatureSAT - Supply Air Temperature SPT - Space Temperature8354 8356 Page WSHP Open Inputs and Outputs Table Fig. 22 - WSHP Open Controla50-8162 Table 3 - 50PCH,PCV Unit Electrical DataFig. 27 - AMV Valve Wiring Step 9 - Wire Field ControlsAccessory Wiring Fig. 24 - Low Voltage Field WiringTable 4 - Field-SuppliedSensors for Table 6 - Rnet Wiring SpecificationsFig. 29 - Rnet Cable Wire Table 7 - Rnet WiringFig. 30 — Blower Speed Selection PRE-START-UPWater Reheat HWR Option Table 8 - 50PCV Blower Performance with HotTable 9 - 50PCV Blower Performance with Wet Coil FIELD SELECTABLE INPUTS Accessory 1 Relay Options START-UPOperating Limits Table 12 - DIP Switch Block S2Through Heat Exchanger Unit Start-UpCooling ModeTable 15 - Water Temperature Change Table 14 - Operating Limits - 50PCH,PCV Units115-125 114-124 Unit Start-Upwith WSHP Open Controls Unit Start-UpHeating ModeFig. 31 - BACview6 Display Interface Table 23 - Coaxial Water Pressure Drop Table 24 - Approximate Fluid Volume gal OPERATIONUnits with Aquazone Complete C Control Units with Aquazone Deluxe D ControlUnits with WSHP Open Multiple Protocol Condensate overflow input is normal Damper control is configured for DCV Fault Descriptions COMPLETE C AND DELUXE D BOARD SYSTEM TESTAquazone Deluxe D Control LED Indica Status and Alarm Relay OperationsSERVICE Fig. 33 - Forced Circulation Method Refrigerant ChargingAir Coil Fan Motor Removal Fig. 32 - Gravity Flow Methoda50-8163 TROUBLESHOOTING Fig. 34 and 35, and TableReplacing the WSHP Open Controller’s Bat Fig. 34 - Thermistor Nominal ResistanceTable 29 - Troubleshooting Table 29 - Troubleshooting cont Space Temperature APPENDIX A - WSHP OPEN SCREEN CONFIGURATIONOutdoor Air Temperature SAT - Supply Air TemperatureSpace Temperature APPENDIX A - WSHP OPEN SCREEN CONFIGURATION contOutdoor Air Temperature SAT - Supply Air TemperatureSpace Temperature APPENDIX A - WSHP OPEN SCREEN CONFIGURATION contOutdoor Air Temperature SAT - Supply Air TemperatureSpace Temperature APPENDIX A - WSHP SCREEN OPEN CONFIGURATION contOutdoor Air Temperature SAT - Supply Air TemperatureAPPENDIX A - WSHP SCREEN OPEN CONFIGURATION cont Space Temperature APPENDIX A - WSHP SCREEN OPEN CONFIGURATION contOutdoor Air Temperature SAT - Supply Air TemperaturePage 7-09 Copyright 2009 Carrier CorporationCatalog No Form 50PC-1SII.PRE-START-UP 50PCH,PCV START-UPCHECKLISTII.START-UP TEMP. DIFF. DEG. F HEATING CYCLE ANALYSISCOOLING CYCLE ANALYSIS FLOW RATE GPM