24-HourService Hotline
Service and Parts Manual
Performance Pro Series Gas Fryers Models
MARCH
DANGER
NOTICE TO U.S. CUSTOMERS
NOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERS
DANGER
DANGER
DANGER
DANGER
Table of Contents CHAPTER 1 Service Procedures
PERFORMANCE PRO SERIES GAS FRYERS MODELS
Table of Contents CHAPTER 2 Parts List
PERFORMANCE PRO SERIES GAS FRYERS MODELS
CHAPTER 1 SERVICE PROCEDURES
PERFORMANCE PRO SERIES GAS FRYERS MODELS
1.1 General
1.1.1 Pilot Ignition
1.2 Moving the Fryer for Servicing
1.1.4 Thermostats and Temperature Probes
1.1.3 Controller Options
1.3 Diagnostic Procedures
1.3.1 Cleaning the Gas Valve Vent Tube
To adjust burner gas pressure
After servicing is complete
12.Place the gas valve in the OFF position
1.3.5 Calibrating the Thermostat
1.3.3 Adjusting the Pilot Flame
Fryers with thermostat access doors
Fryers with thermostat control panels
1.4.1 Replacing a Controller or Computer
1.3.6 Testing the Temperature Probe
1.4 Replacing Fryer Components
2.Drain the frypot
1.4.4 Replacing the Temperature Probe
CAUTION Drain the frypot before pro- ceeding
1-10
1.4.9 Replacing Burner Ceramic Targets
1.4.10 Replacing the Gas Valve
1.4.11 Replacing the Pilot Assembly or Thermopile
Drain the frypot or remove the
handle from the drain valve
before proceeding further
16.Remove the flue cap
DANGER
1.5 Troubleshooting and Problem Isolation
1.4.13 Replacing a Pump/Motor
1.5.1 Typical Problems
The Gas and Electrical Power Supplies
Pilot Failure
No pilot flame
The Electronic Circuits
The Gas Valve
Improper Burner Function
Incorrect or Fluctuating Gas Pressure
Inadequate Make-upAir
Other Causes of Popping
Page
Common Computer Complaints
Filtration Malfunction
Modular Basket Lift Simplified Schematic
Modular Basket Lift Simplified Schematic
Timer
N.O Upper Limit Microswitch
Leakage
Basket Lift Malfunction
Electronics Failure
Binds and Jams
Motor and Gear Wear
1.6 Probe Resistance Chart Probe Resistance Chart
1.5.2 Interpretation of Analog Controller Lights
1.7 Troubleshooting Guides
1.7.2 Troubleshooting the Gas Valve
1.7.3 Troubleshooting the Thermostat
1.7.4 Troubleshooting the Temperature Probe
1.8Wiring Diagrams 1.8.1 Standing Pilot
1.8.2 Electronic Ignition
1.8.3 Non-ComputerControlled Fryer
1.8.4 Electronic Ignition
1.8.5 Filter Box
8050902D
1.8.6 Modular Basket Lift 100/120V
1.8.7 Modular Basket Lift 208/250V
CHAPTER 2 PARTS LIST
2.1 Accessories
PERFORMANCE PRO SERIES GAS FRYERS MODELS
PART #
2.2 Basket Lift and Associated Parts
100-120VConfiguration
208-250VConfiguration
4.Wiring has been omitted for clarity
Basket Lift Assemblies
PART #
COMPONENT
2.3 Cabinetry 2.3.1 FPP/FMP Model Cabinetry
Front of fryer
Rear of fryer
Four station fryer shown
PART #
COMPONENT
Cabinet Assemblies see Section
Base Assemblies
2.3.2 PMJ Non-filterModel Cabinetry
Front of fryer
Rear of fryer
Four station fryer shown
Other Components
PART #
COMPONENT
2.4 Casters, Legs, and Associated Hardware
PART #
COMPONENT
PART #
2.5 Component Boxes
Full-vatComponent Box Assembly
Full-vatComponent Box Assembly
with Melt Cycle Timer
Not illustrated
2-10
PART #
COMPONENT
Page
Thermostat Access Door MJ
PART #
COMPONENT
Control Panel Assemblies
2.7 Controller Assemblies
Basket Lift Timer
PART #
COMPONENT
Remote Computer/Controller Cable Assemblies
Wiring Assemblies and Harnesses
2-14
PART #
2.8 Door Assembly
106-3965 Door Assembly
PART #
COMPONENT
Drain Tubes
Miscellaneous
2.9.2 Drain Valves FPP/FMP Models
Full-vatAssembly
Dual-vat,Left Assembly
Dual-vat,Right Assembly
Drain Safety Switch
PART #
COMPONENT
Drain Valve Assemblies
2.9.3 Drain Valves PMJ Models
PART #
2.10 Filter Boxes
120V Assembly
208-240VAssembly
208-250VAssembly
PART #
COMPONENT
Complete Box Assemblies
Components
COMPONENT
2.11 Filter Pan Assembly
PART #
COMPONENT
2.12 Frypots
PART #
2.13 Frypot Cabinetry
2.13.1 PMJ45 Frypot Cabinetry
PART #
COMPONENT
COMPONENT
2.13.2 PMJ35 Frypot Cabinetry
PART #
2.14 Gas Valves and Burners
2.14.1 PMJ45 Gas Valves and Burners
PART #
COMPONENT
PART #
COMPONENT
Pilot Assemblies, Non-CE
Pilot Assemblies, CE and Export
2.14.2 PMJ35 Gas Valves and Burners
Gas Valve Conversion Kits
3Non-CENatural to Propane
Non-CEPropane to Natural
PART #
COMPONENT
Pilot Assemblies, Non-CE
Pilot Assemblies, CE and Export
COMPONENT
2.14.3 Ignitors
PART #
2.15 Oil Return Components
115V Pump/Motor Assembly shown
Filter Return Manifold
Filter Suction Manifold
PART #
COMPONENT
Oil Return Components continued on next page
Handle Assemblies, Oil Return Valve
2.16 Oil Return Assembly
PART #
COMPONENT
PART #
2.17 Thermostats and Timers
Operating Thermostat Assembly, Fenwall
Timers, Basket Lift
COMPONENT
Connectors
COMPONENT
2.20 Power Shower
2.19 Garland Range S35 Parts
Power Shower Assembly
COMPONENT
March
SERVICE HOTLINE
819-6092