Performance Pro Series Gas Fryers Models
24-HourService Hotline
Service and Parts Manual
MARCH
NOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERS
NOTICE TO U.S. CUSTOMERS
DANGER
DANGER
DANGER
DANGER
DANGER
Table of Contents CHAPTER 1 Service Procedures
PERFORMANCE PRO SERIES GAS FRYERS MODELS
Table of Contents CHAPTER 2 Parts List
PERFORMANCE PRO SERIES GAS FRYERS MODELS
1.1 General
CHAPTER 1 SERVICE PROCEDURES
PERFORMANCE PRO SERIES GAS FRYERS MODELS
1.1.1 Pilot Ignition
1.1.3 Controller Options
1.1.4 Thermostats and Temperature Probes
1.2 Moving the Fryer for Servicing
To adjust burner gas pressure
1.3 Diagnostic Procedures
1.3.1 Cleaning the Gas Valve Vent Tube
After servicing is complete
12.Place the gas valve in the OFF position
Fryers with thermostat access doors
1.3.3 Adjusting the Pilot Flame
1.3.5 Calibrating the Thermostat
Fryers with thermostat control panels
1.4 Replacing Fryer Components
1.3.6 Testing the Temperature Probe
1.4.1 Replacing a Controller or Computer
2.Drain the frypot
1.4.4 Replacing the Temperature Probe
CAUTION Drain the frypot before pro- ceeding
1-10
1.4.9 Replacing Burner Ceramic Targets
1.4.10 Replacing the Gas Valve
handle from the drain valve
1.4.11 Replacing the Pilot Assembly or Thermopile
Drain the frypot or remove the
before proceeding further
16.Remove the flue cap
1.4.13 Replacing a Pump/Motor
1.5 Troubleshooting and Problem Isolation
DANGER
Pilot Failure
1.5.1 Typical Problems
The Gas and Electrical Power Supplies
No pilot flame
Improper Burner Function
The Electronic Circuits
The Gas Valve
Incorrect or Fluctuating Gas Pressure
Inadequate Make-upAir
Other Causes of Popping
Page
Common Computer Complaints
Filtration Malfunction
Timer
Modular Basket Lift Simplified Schematic
Modular Basket Lift Simplified Schematic
N.O Upper Limit Microswitch
Leakage
Basket Lift Malfunction
Motor and Gear Wear
Binds and Jams
Electronics Failure
1.6 Probe Resistance Chart Probe Resistance Chart
1.5.2 Interpretation of Analog Controller Lights
1.7 Troubleshooting Guides
1.7.2 Troubleshooting the Gas Valve
1.7.3 Troubleshooting the Thermostat
1.7.4 Troubleshooting the Temperature Probe
1.8Wiring Diagrams 1.8.1 Standing Pilot
1.8.2 Electronic Ignition
1.8.3 Non-ComputerControlled Fryer
1.8.4 Electronic Ignition
1.8.5 Filter Box
8050902D
1.8.6 Modular Basket Lift 100/120V
1.8.7 Modular Basket Lift 208/250V
PERFORMANCE PRO SERIES GAS FRYERS MODELS
CHAPTER 2 PARTS LIST
2.1 Accessories
PART #
208-250VConfiguration
2.2 Basket Lift and Associated Parts
100-120VConfiguration
4.Wiring has been omitted for clarity
COMPONENT
PART #
Basket Lift Assemblies
Rear of fryer
2.3 Cabinetry 2.3.1 FPP/FMP Model Cabinetry
Front of fryer
Four station fryer shown
Cabinet Assemblies see Section
PART #
COMPONENT
Base Assemblies
Rear of fryer
2.3.2 PMJ Non-filterModel Cabinetry
Front of fryer
Four station fryer shown
COMPONENT
PART #
Other Components
COMPONENT
2.4 Casters, Legs, and Associated Hardware
PART #
PART #
Full-vatComponent Box Assembly
2.5 Component Boxes
Full-vatComponent Box Assembly
with Melt Cycle Timer
PART #
Not illustrated
2-10
COMPONENT
Page
COMPONENT
Thermostat Access Door MJ
PART #
Control Panel Assemblies
PART #
2.7 Controller Assemblies
Basket Lift Timer
COMPONENT
2-14
Wiring Assemblies and Harnesses
Remote Computer/Controller Cable Assemblies
106-3965 Door Assembly
2.8 Door Assembly
PART #
Drain Tubes
PART #
COMPONENT
Miscellaneous
Dual-vat,Left Assembly
2.9.2 Drain Valves FPP/FMP Models
Full-vatAssembly
Dual-vat,Right Assembly
COMPONENT
Drain Safety Switch
PART #
Drain Valve Assemblies
2.9.3 Drain Valves PMJ Models
PART #
208-240VAssembly
2.10 Filter Boxes
120V Assembly
208-250VAssembly
Complete Box Assemblies
PART #
COMPONENT
Components
PART #
2.11 Filter Pan Assembly
COMPONENT
PART #
2.12 Frypots
COMPONENT
PART #
2.13 Frypot Cabinetry
2.13.1 PMJ45 Frypot Cabinetry
COMPONENT
PART #
2.13.2 PMJ35 Frypot Cabinetry
COMPONENT
PART #
2.14 Gas Valves and Burners
2.14.1 PMJ45 Gas Valves and Burners
COMPONENT
Pilot Assemblies, Non-CE
PART #
COMPONENT
Pilot Assemblies, CE and Export
3Non-CENatural to Propane
2.14.2 PMJ35 Gas Valves and Burners
Gas Valve Conversion Kits
Non-CEPropane to Natural
Pilot Assemblies, Non-CE
PART #
COMPONENT
Pilot Assemblies, CE and Export
PART #
2.14.3 Ignitors
COMPONENT
Filter Return Manifold
2.15 Oil Return Components
115V Pump/Motor Assembly shown
Filter Suction Manifold
Oil Return Components continued on next page
PART #
COMPONENT
Handle Assemblies, Oil Return Valve
COMPONENT
2.16 Oil Return Assembly
PART #
PART #
Timers, Basket Lift
2.17 Thermostats and Timers
Operating Thermostat Assembly, Fenwall
COMPONENT
Connectors
COMPONENT
Power Shower Assembly
2.20 Power Shower
2.19 Garland Range S35 Parts
COMPONENT
819-6092
SERVICE HOTLINE
March