MARCH
24-HourService Hotline
Service and Parts Manual
Performance Pro Series Gas Fryers Models
NOTICE TO U.S. CUSTOMERS
NOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERS
DANGER
DANGER
DANGER
DANGER
DANGER
PERFORMANCE PRO SERIES GAS FRYERS MODELS
Table of Contents CHAPTER 1 Service Procedures
PERFORMANCE PRO SERIES GAS FRYERS MODELS
Table of Contents CHAPTER 2 Parts List
1.1.1 Pilot Ignition
CHAPTER 1 SERVICE PROCEDURES
PERFORMANCE PRO SERIES GAS FRYERS MODELS
1.1 General
1.1.4 Thermostats and Temperature Probes
1.1.3 Controller Options
1.2 Moving the Fryer for Servicing
After servicing is complete
1.3 Diagnostic Procedures
1.3.1 Cleaning the Gas Valve Vent Tube
To adjust burner gas pressure
12.Place the gas valve in the OFF position
1.3.3 Adjusting the Pilot Flame
Fryers with thermostat access doors
1.3.5 Calibrating the Thermostat
Fryers with thermostat control panels
1.3.6 Testing the Temperature Probe
1.4 Replacing Fryer Components
1.4.1 Replacing a Controller or Computer
2.Drain the frypot
CAUTION Drain the frypot before pro- ceeding
1.4.4 Replacing the Temperature Probe
1-10
1.4.10 Replacing the Gas Valve
1.4.9 Replacing Burner Ceramic Targets
before proceeding further
1.4.11 Replacing the Pilot Assembly or Thermopile
Drain the frypot or remove the
handle from the drain valve
16.Remove the flue cap
1.5 Troubleshooting and Problem Isolation
1.4.13 Replacing a Pump/Motor
DANGER
No pilot flame
1.5.1 Typical Problems
The Gas and Electrical Power Supplies
Pilot Failure
Incorrect or Fluctuating Gas Pressure
The Electronic Circuits
The Gas Valve
Improper Burner Function
Other Causes of Popping
Inadequate Make-upAir
Page
Common Computer Complaints
Filtration Malfunction
N.O Upper Limit Microswitch
Modular Basket Lift Simplified Schematic
Modular Basket Lift Simplified Schematic
Timer
Basket Lift Malfunction
Leakage
Binds and Jams
Motor and Gear Wear
Electronics Failure
1.5.2 Interpretation of Analog Controller Lights
1.6 Probe Resistance Chart Probe Resistance Chart
1.7 Troubleshooting Guides
1.7.3 Troubleshooting the Thermostat
1.7.2 Troubleshooting the Gas Valve
1.7.4 Troubleshooting the Temperature Probe
1.8Wiring Diagrams 1.8.1 Standing Pilot
1.8.2 Electronic Ignition
1.8.3 Non-ComputerControlled Fryer
1.8.4 Electronic Ignition
8050902D
1.8.5 Filter Box
1.8.6 Modular Basket Lift 100/120V
1.8.7 Modular Basket Lift 208/250V
PART #
CHAPTER 2 PARTS LIST
2.1 Accessories
PERFORMANCE PRO SERIES GAS FRYERS MODELS
4.Wiring has been omitted for clarity
2.2 Basket Lift and Associated Parts
100-120VConfiguration
208-250VConfiguration
PART #
COMPONENT
Basket Lift Assemblies
Four station fryer shown
2.3 Cabinetry 2.3.1 FPP/FMP Model Cabinetry
Front of fryer
Rear of fryer
Base Assemblies
PART #
COMPONENT
Cabinet Assemblies see Section
Four station fryer shown
2.3.2 PMJ Non-filterModel Cabinetry
Front of fryer
Rear of fryer
PART #
COMPONENT
Other Components
PART #
2.4 Casters, Legs, and Associated Hardware
PART #
COMPONENT
with Melt Cycle Timer
2.5 Component Boxes
Full-vatComponent Box Assembly
Full-vatComponent Box Assembly
COMPONENT
Not illustrated
2-10
PART #
Page
Control Panel Assemblies
Thermostat Access Door MJ
PART #
COMPONENT
COMPONENT
2.7 Controller Assemblies
Basket Lift Timer
PART #
Wiring Assemblies and Harnesses
2-14
Remote Computer/Controller Cable Assemblies
2.8 Door Assembly
106-3965 Door Assembly
PART #
Miscellaneous
PART #
COMPONENT
Drain Tubes
Dual-vat,Right Assembly
2.9.2 Drain Valves FPP/FMP Models
Full-vatAssembly
Dual-vat,Left Assembly
Drain Valve Assemblies
Drain Safety Switch
PART #
COMPONENT
PART #
2.9.3 Drain Valves PMJ Models
208-250VAssembly
2.10 Filter Boxes
120V Assembly
208-240VAssembly
Components
PART #
COMPONENT
Complete Box Assemblies
2.11 Filter Pan Assembly
PART #
COMPONENT
2.12 Frypots
PART #
COMPONENT
COMPONENT
2.13 Frypot Cabinetry
2.13.1 PMJ45 Frypot Cabinetry
PART #
2.13.2 PMJ35 Frypot Cabinetry
PART #
COMPONENT
COMPONENT
2.14 Gas Valves and Burners
2.14.1 PMJ45 Gas Valves and Burners
PART #
Pilot Assemblies, CE and Export
PART #
COMPONENT
Pilot Assemblies, Non-CE
Non-CEPropane to Natural
2.14.2 PMJ35 Gas Valves and Burners
Gas Valve Conversion Kits
3Non-CENatural to Propane
Pilot Assemblies, CE and Export
PART #
COMPONENT
Pilot Assemblies, Non-CE
2.14.3 Ignitors
PART #
COMPONENT
Filter Suction Manifold
2.15 Oil Return Components
115V Pump/Motor Assembly shown
Filter Return Manifold
Handle Assemblies, Oil Return Valve
PART #
COMPONENT
Oil Return Components continued on next page
PART #
2.16 Oil Return Assembly
PART #
COMPONENT
COMPONENT
2.17 Thermostats and Timers
Operating Thermostat Assembly, Fenwall
Timers, Basket Lift
COMPONENT
Connectors
COMPONENT
2.20 Power Shower
2.19 Garland Range S35 Parts
Power Shower Assembly
SERVICE HOTLINE
819-6092
March