Service and Parts Manual
24-HourService Hotline
Performance Pro Series Gas Fryers Models
MARCH
DANGER
NOTICE TO U.S. CUSTOMERS
NOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERS
DANGER
DANGER
DANGER
DANGER
PERFORMANCE PRO SERIES GAS FRYERS MODELS
Table of Contents CHAPTER 1 Service Procedures
PERFORMANCE PRO SERIES GAS FRYERS MODELS
Table of Contents CHAPTER 2 Parts List
PERFORMANCE PRO SERIES GAS FRYERS MODELS
CHAPTER 1 SERVICE PROCEDURES
1.1 General
1.1.1 Pilot Ignition
1.2 Moving the Fryer for Servicing
1.1.4 Thermostats and Temperature Probes
1.1.3 Controller Options
1.3.1 Cleaning the Gas Valve Vent Tube
1.3 Diagnostic Procedures
To adjust burner gas pressure
After servicing is complete
12.Place the gas valve in the OFF position
1.3.5 Calibrating the Thermostat
1.3.3 Adjusting the Pilot Flame
Fryers with thermostat access doors
Fryers with thermostat control panels
1.4.1 Replacing a Controller or Computer
1.3.6 Testing the Temperature Probe
1.4 Replacing Fryer Components
2.Drain the frypot
CAUTION Drain the frypot before pro- ceeding
1.4.4 Replacing the Temperature Probe
1-10
1.4.10 Replacing the Gas Valve
1.4.9 Replacing Burner Ceramic Targets
Drain the frypot or remove the
1.4.11 Replacing the Pilot Assembly or Thermopile
handle from the drain valve
before proceeding further
16.Remove the flue cap
DANGER
1.5 Troubleshooting and Problem Isolation
1.4.13 Replacing a Pump/Motor
The Gas and Electrical Power Supplies
1.5.1 Typical Problems
Pilot Failure
No pilot flame
The Gas Valve
The Electronic Circuits
Improper Burner Function
Incorrect or Fluctuating Gas Pressure
Other Causes of Popping
Inadequate Make-upAir
Page
Common Computer Complaints
Filtration Malfunction
Modular Basket Lift Simplified Schematic
Modular Basket Lift Simplified Schematic
Timer
N.O Upper Limit Microswitch
Basket Lift Malfunction
Leakage
Electronics Failure
Binds and Jams
Motor and Gear Wear
1.5.2 Interpretation of Analog Controller Lights
1.6 Probe Resistance Chart Probe Resistance Chart
1.7 Troubleshooting Guides
1.7.3 Troubleshooting the Thermostat
1.7.2 Troubleshooting the Gas Valve
1.7.4 Troubleshooting the Temperature Probe
1.8Wiring Diagrams 1.8.1 Standing Pilot
1.8.2 Electronic Ignition
1.8.3 Non-ComputerControlled Fryer
1.8.4 Electronic Ignition
8050902D
1.8.5 Filter Box
1.8.6 Modular Basket Lift 100/120V
1.8.7 Modular Basket Lift 208/250V
2.1 Accessories
CHAPTER 2 PARTS LIST
PERFORMANCE PRO SERIES GAS FRYERS MODELS
PART #
100-120VConfiguration
2.2 Basket Lift and Associated Parts
208-250VConfiguration
4.Wiring has been omitted for clarity
Basket Lift Assemblies
PART #
COMPONENT
Front of fryer
2.3 Cabinetry 2.3.1 FPP/FMP Model Cabinetry
Rear of fryer
Four station fryer shown
COMPONENT
PART #
Cabinet Assemblies see Section
Base Assemblies
Front of fryer
2.3.2 PMJ Non-filterModel Cabinetry
Rear of fryer
Four station fryer shown
Other Components
PART #
COMPONENT
PART #
2.4 Casters, Legs, and Associated Hardware
COMPONENT
PART #
Full-vatComponent Box Assembly
2.5 Component Boxes
Full-vatComponent Box Assembly
with Melt Cycle Timer
2-10
Not illustrated
PART #
COMPONENT
Page
PART #
Thermostat Access Door MJ
COMPONENT
Control Panel Assemblies
Basket Lift Timer
2.7 Controller Assemblies
PART #
COMPONENT
Remote Computer/Controller Cable Assemblies
Wiring Assemblies and Harnesses
2-14
PART #
2.8 Door Assembly
106-3965 Door Assembly
COMPONENT
PART #
Drain Tubes
Miscellaneous
Full-vatAssembly
2.9.2 Drain Valves FPP/FMP Models
Dual-vat,Left Assembly
Dual-vat,Right Assembly
PART #
Drain Safety Switch
COMPONENT
Drain Valve Assemblies
PART #
2.9.3 Drain Valves PMJ Models
120V Assembly
2.10 Filter Boxes
208-240VAssembly
208-250VAssembly
COMPONENT
PART #
Complete Box Assemblies
Components
COMPONENT
2.11 Filter Pan Assembly
PART #
COMPONENT
2.12 Frypots
PART #
2.13.1 PMJ45 Frypot Cabinetry
2.13 Frypot Cabinetry
PART #
COMPONENT
COMPONENT
2.13.2 PMJ35 Frypot Cabinetry
PART #
2.14.1 PMJ45 Gas Valves and Burners
2.14 Gas Valves and Burners
PART #
COMPONENT
COMPONENT
PART #
Pilot Assemblies, Non-CE
Pilot Assemblies, CE and Export
Gas Valve Conversion Kits
2.14.2 PMJ35 Gas Valves and Burners
3Non-CENatural to Propane
Non-CEPropane to Natural
COMPONENT
PART #
Pilot Assemblies, Non-CE
Pilot Assemblies, CE and Export
COMPONENT
2.14.3 Ignitors
PART #
115V Pump/Motor Assembly shown
2.15 Oil Return Components
Filter Return Manifold
Filter Suction Manifold
COMPONENT
PART #
Oil Return Components continued on next page
Handle Assemblies, Oil Return Valve
PART #
2.16 Oil Return Assembly
COMPONENT
PART #
Operating Thermostat Assembly, Fenwall
2.17 Thermostats and Timers
Timers, Basket Lift
COMPONENT
COMPONENT
Connectors
2.19 Garland Range S35 Parts
2.20 Power Shower
Power Shower Assembly
COMPONENT
March
SERVICE HOTLINE
819-6092