Manuals / Frymaster / Kitchen Appliance / Fryer

Frymaster 47 Series operation manual Series Gas Fryers, 819-5383

Models: 47 Series

1 44

Download 44 pages 48.19 Kb

Page 1

Installation & Operation Manual

Installation & Operation Manual

47 Series Gas Fryers

Frymaster, a member of the Commercial Food Equipment Service Association, recommends using CFESA Certified Technicians.

	24-Hour Service Hotline 1-800-551-8633	819-5383
	24-Hour Service Hotline 1-800-551-8633	SEP 2002
		SEP 2002

Image 1

Frymaster 47 Series operation manual Series Gas Fryers, 819-5383

Contents

819-5383 47 Series Gas FryersNOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERS NOTICE TO U.S. CUSTOMERSCANADA DANGERDANGER DANGERDANGER DANGER47 SERIES GAS FRYERS TABLE OF CONTENTS CHAPTER 1 GENERAL INFORMATION 47 SERIES GAS FRYERS1.2Parts Ordering and Service Information 1.1Applicability and Validity1.3Safety Information malfunction of your systemNon-CEStandard for IncomingGas Pressures DANGERQUALIFIED AND/OR AUTHORIZED OPERATING PERSONNEL QUALIFIED INSTALLATION PERSONNEL1.6Installation, Operating, and Service Personnel 1.7DefinitionsWarranty on your equipment QUALIFIED SERVICE PERSONNEL1.8Shipping Damage Claim Procedure What to do if your equipment arrives damaged47 SERIES GAS FRYERS CHAPTER 2 INSTALLATION INSTRUCTIONSDANGER DANGERNATIONAL CODE REQUIREMENTS ELECTRICAL GROUNDING REQUIREMENTSDANGER 2.2Caster/Leg InstallationDANGER FCC COMPLIANCEDANGER 2.3Pre-ConnectionPreparations DANGER2.4Connection to Gas Line DANGER Non-CEStandard for Incoming Gas PressuresCE Standard Gas Connection Pipe SizesCE Standard Burner Manifold Gas Pressures 6.Place the fryer ON/OFF switch in the ON position 2.5Converting to Another Gas Type CE and Non-CEGas Conversion Instructions 47 SERIES GAS FRYERS CHAPTER 3 OPERATING INSTRUCTIONS2.Push the knob in and light the pilot. If the fryer is equipped with a piezo ignitor, repeatedly press the piezo ignitor button while depressing the gas valve knob until the pilot lights. Continue to hold the knob in for about 60 seconds after the flame appears on the pilot. Release the knob. The pilot should remain lit PLACING THE FRYER INTO OPERATION For units equipped with Thermostat Controls3.3Shutting the Fryer Down DANGER3.4Controller Operation and Programming 47 SERIES GAS FRYERS CHAPTER 4 FILTRATION INSTRUCTIONSDANGER Page 4.2.3 Operating the Filter Unit Page DANGER Inspect Fryer and Accessories for Damage CHAPTER 5 PREVENTIVE MAINTENANCEClean Fryer Cabinet Inside and Out Check Recovery TimeClean Detachable Parts and Accessories Drain and Clean FrypotQUARTERLY CHECKS AND SERVICES Check Computer Magic III Set Point Accuracy Clean Gas Valve Vent TubeSEMI-ANNUALCHECKS AND SERVICES Check Burner Manifold PressureDANGER DANGERBuilt-InFiltration System Page Verify that any gas line cutoff valves are open CHAPTER 6 OPERATOR TROUBLESHOOTINGVerify that frypot drain valves are fully closed 47 SERIES GAS FRYERSBurner will not controller power andlight Solid state analogindicator is on but indicator does notTimer, or Digital switch is in the ONnormally, but flames Fryer is operatingare rolling out of the front of the burnertransfer takes place Pump starts, but noor the transfer is very slowspraying properly Power Shower is notPROBLEM PROBABLE CAUSES1.Disconnect the fryer from the electrical supply THIS PAGE INTENTIONALLY LEFT BLANK FAX Parts SERVICE HOTLINETech Support Price $18.00