Manuals / Frymaster / Kitchen Appliance / Fryer

Frymaster 47 Series FAX Parts, Tech Support, Service Hotline, Price $18.00, 819-5383

Models: 47 Series

1 44

Download 44 pages 48.19 Kb

Page 44

FAX (Parts) 1-318-219-7140

Frymaster, L.L.C., 8700 Line Avenue, PO Box 51000, Shreveport, Louisiana 71135-1000

Shipping Address: 8700 Line Avenue, Shreveport, Louisiana 71106

TEL 1-318-865-1711	FAX (Parts) 1-318-219-7140	(Tech Support) 1-318-219-7135
	SERVICE HOTLINE	Price: $18.00
PRINTED IN THE UNITED STATES	1-800-551-8633	819-5383
		SEP 2002

Image 44

Frymaster 47 Series operation manual FAX Parts, Tech Support, Service Hotline, Price $18.00, 819-5383

Contents

47 Series Gas Fryers 819-5383NOTICE TO U.S. CUSTOMERS NOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERSCANADA DANGERDANGER DANGERDANGER DANGER47 SERIES GAS FRYERS TABLE OF CONTENTS 47 SERIES GAS FRYERS CHAPTER 1 GENERAL INFORMATION1.2Parts Ordering and Service Information 1.1Applicability and Validitymalfunction of your system 1.3Safety InformationNon-CEStandard for IncomingGas Pressures DANGERQUALIFIED INSTALLATION PERSONNEL QUALIFIED AND/OR AUTHORIZED OPERATING PERSONNEL1.6Installation, Operating, and Service Personnel 1.7DefinitionsQUALIFIED SERVICE PERSONNEL Warranty on your equipment1.8Shipping Damage Claim Procedure What to do if your equipment arrives damagedCHAPTER 2 INSTALLATION INSTRUCTIONS 47 SERIES GAS FRYERSDANGER DANGERNATIONAL CODE REQUIREMENTS ELECTRICAL GROUNDING REQUIREMENTS2.2Caster/Leg Installation DANGERDANGER FCC COMPLIANCE2.3Pre-ConnectionPreparations DANGER DANGERNon-CEStandard for Incoming Gas Pressures 2.4Connection to Gas Line DANGERGas Connection Pipe Sizes CE StandardCE Standard Burner Manifold Gas Pressures 6.Place the fryer ON/OFF switch in the ON position 2.5Converting to Another Gas Type CE and Non-CEGas Conversion Instructions CHAPTER 3 OPERATING INSTRUCTIONS 47 SERIES GAS FRYERS2.Push the knob in and light the pilot. If the fryer is equipped with a piezo ignitor, repeatedly press the piezo ignitor button while depressing the gas valve knob until the pilot lights. Continue to hold the knob in for about 60 seconds after the flame appears on the pilot. Release the knob. The pilot should remain lit For units equipped with Thermostat Controls PLACING THE FRYER INTO OPERATIONDANGER 3.3Shutting the Fryer Down3.4Controller Operation and Programming CHAPTER 4 FILTRATION INSTRUCTIONS 47 SERIES GAS FRYERSDANGER Page 4.2.3 Operating the Filter Unit Page DANGER CHAPTER 5 PREVENTIVE MAINTENANCE Inspect Fryer and Accessories for DamageClean Fryer Cabinet Inside and Out Check Recovery TimeQUARTERLY CHECKS AND SERVICES Drain and Clean FrypotClean Detachable Parts and Accessories Clean Gas Valve Vent Tube Check Computer Magic III Set Point AccuracyCheck Burner Manifold Pressure SEMI-ANNUALCHECKS AND SERVICESDANGER DANGERBuilt-InFiltration System Page CHAPTER 6 OPERATOR TROUBLESHOOTING Verify that any gas line cutoff valves are openVerify that frypot drain valves are fully closed 47 SERIES GAS FRYERScontroller power and Burner will notlight Solid state analogindicator does not indicator is on butTimer, or Digital switch is in the ONFryer is operating normally, but flamesare rolling out of the front of the burnerPump starts, but no transfer takes placeor the transfer is very slowPower Shower is not spraying properlyPROBLEM PROBABLE CAUSES1.Disconnect the fryer from the electrical supply THIS PAGE INTENTIONALLY LEFT BLANK SERVICE HOTLINE FAX PartsTech Support Price $18.00