Frymaster FBKR18 Series, FBCR18 manual Computer, Part of J2, J411, INTERFACE BOARD J2, On/Off

Models: FBKR18 Series FBCR18

COMPUTER

INTERFACE BOARD

Part of J2

ON/OFF

Manuals / Frymaster / Kitchen Appliance / Kitchen Entertainment Center

1 60

Download 60 pages 39.53 Kb

Page 53

Image 53

J2 806-9295

LOW	HIGH
WATER	WATER
SENSOR	SENSOR

J3	J5
24VAC	24VAC
U2A	U2D

TEMPERATURE

PROBE

6-20

120VAC IN

U2B	U2C
10

2	K6	K5
	WATER	K5
	WATER

HEAT

K2K1

4WATER

SOUND DEVICE	Q3	K4
SOUND DEVICE		HEAT
12
1
J411	10	1

ALARM

K3 Q2

LATCH

		LATCH
3	5	4	14	13

OPTIONAL BASKET LIFTS


LEFT		RIGHT
PRODUCT		PRODUCT
BUTTONS		BUTTONS

Page 53

Image 53

Frymaster FBKR18 Series, FBCR18 manual Computer, Part of J2, J411, INTERFACE BOARD J2, On/Off

Contents

819-5686 24-Hour Service HotlineMarch FBCR18 & FBKR18 SeriesNOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERS U.S NOTICE TO U.S. CUSTOMERSCANADA DANGERPage CHAPTER 2 Installation Instructions FBCR18 & FBKR18 SERIES GAS RETHERMALIZERS TABLE OF CONTENTSCHAPTER 4 Preventive Maintenance CHAPTER 1 General InformationCHAPTER 6 Service Procedures CHAPTER 5 Operator TroubleshootingCHAPTER 7 Parts List Interface BoardFBCR18 & FBKR18 SERIES GAS RETHERMALIZERS 1.2 Parts Ordering and Service InformationCHAPTER 1 GENERAL INFORMATION 1.1 Applicability and Validity1.5 Installation, Operating, and Service Personnel 1.3 Safety InformationDANGER 1.4 Equipment Description1.7 Shipping Damage Claim Procedure Warranty on your equipment1.6 Definitions What to do if your equipment arrives damaged2.1 General Installation Requirements CHAPTER 2 INSTALLATION INSTRUCTIONSFBCR18 & FBKR18 SERIES GAS RETHERMALIZERS DANGERDANGER DANGERDANGER NATIONAL CODE REQUIREMENTS2.3 Pre-Connection Preparations DANGER 2.2 Caster/Leg InstallationDANGER Incoming Gas PressuresMinimum MaximumDANGER 2.4 Connecting to the Gas Supply DANGERDANGER DANGERDANGER 2.5 Converting to Another Gas Type2. Open the gas supply to the fryer and check all piping, fittings, and gas connections for leaks. A soap and water solution should be used for this purpose 3.1 Introduction CHAPTER 3 OPERATING INSTRUCTIONS3.2 FBCR18 Series Computer FBCR18 & FBKR18 SERIES GAS RETHERMALIZERSOPERATING THE FBCR18 SERIES RETHERMALIZER USING THE FBCR18 CHILL FEATUREPROGRAMMING THE FBCR18 SERIES COMPUTER FBCR18 COMPUTER DISPLAY MESSAGES 3.3 FBKR18 Series ComputerFBCR18 TEMPERATURE DISPLAY OPTIONS PROGRAMMING THE FBKR18 SERIES COMPUTER FBKR18 Series ComputerPage FBKR18 TEMPERATURE DISPLAY OPTIONS OPERATING THE FBKR18 SERIES RETHERMALIZERFBKR18 CLOCK SPEED OPTIONS FBKR18 COMPUTER DISPLAY MESSAGESFBKR18 BOIL OR SIMMER MODE OPTIONS 3.4 Start-Up Procedure Applies to both the FBCR18 and FBKR18 3.6 Shutting the Rethermalizer Down 3.5 Boiling-Out the Cookpot DANGER4.1 Daily Checks and Services CHAPTER 4 PREVENTIVE MAINTENANCEInspect Rethermalizer and Accessories for Damage Clean Cabinet Inside and Out4.3 Semi-Annual Checks and Services 4.2 Quarterly Checks and ServicesClean Combustion Air Blower Check Computer Magic III Set Point AccuracyCheck Burner Manifold Pressure Clean Gas Valve Vent TubeDANGER Vent Tube3. Place the gas valve in the ON position. Place the computer power switch in the ON position. When the burner lights and continues to burn, compare the indicated pressure to the table below DANGER 5.1 Introduction DANGER5.2 Troubleshooting Guides WATER NOT HEATING. AUTOFILL WORKED PROPERLY Press the Temperature BURNERS DO NOT LIGHT Problem is beyond scope of operator troubleshooting Wiring Harness Connection Ground Wire 5.3 Replacing the Computer or Computer Wiring Harness6.1 Functional Description CHAPTER 6 SERVICE PROCEDURESFBCR18 & FBKR18 SERIES GAS RETHERMALIZERS THE ELECTRONIC IGNITION SYSTEMINTERFACE BOARD Inside the Ignition ModuleCOMPUTERS DANGER 6.2 Accessing the Rethermalizer for Servicing DANGERTEMPERATURE PROBE WATER LEVEL SENSORS6.6.1 Replacing the Computer or Computer Wiring Harness 6.3 Cleaning the Gas Valve Vent Tube6.4 Checking the Burner Manifold Gas Pressure 6.5 Measuring Flame Current6.6.3 Replacing the Interface Board 6.6.2 Replacing the Temperature Probe6.6.4 Replacing an Ignition Module 6.6.5 Replacing an Ignitor Assembly6.6.6 Replacing the Combustion Air Blower 6.6.7 Replacing the Gas Valve6.6.8 Replacing a Burner Assembly 6.6.9 Replacing the Cookpot 6.7 Troubleshooting and Problem IsolationPROBLEMS RELATED TO THE ELECTRONIC CIRCUITS 6.7.1 Ignition FailuresPROBLEMS RELATED TO THE GAS AND/OR ELECTRICAL POWER SUPPLIES Incoming Gas Pressures 6.7.2 Improper Burner Functioning6-11 DANGER6.7.3 Improper Temperature Control 6.7.4 Computer-Related Problems6.8 Troubleshooting Guides 6.8.1 Troubleshooting the Gas Valve 6.8.2 Troubleshooting the 24 VAC Circuit VALVE THE 24VAC CIRCUIT6.8.3 Troubleshooting the Temperature Probe OHMS Probe Resistance ChartOHMS OHMSFBKR18 ONLY 6.9 Simplified Wiring Diagrams8050875F INTERFACE BOARDPIN J2 PIN J1 Part of J2 COMPUTERJ411 INTERFACE BOARD J27.1 Burner System Components FBCR18 & FBKR18 SERIES GAS RETHERMALIZERS CHAPTER 7 PARTS LISTITEM PART # COMPONENT7 900-7377 Side, Cabinet, CRS for S/S units, use 7.2 Cabinetry and Associated ComponentsITEM PART # COMPONENTPART # 7.3 Computer, Component Box Assembly, and Associated PartsCOMPONENT to each otherPART # 7.4 Cookpot and Associated PartsCOMPONENT 806-7552SPCOMPONENT 7.5 Gas Supply ComponentsPART # PART # 7.6 Plumbing ComponentsCOMPONENT NOTE Valve handle nutShipping Address 8700 Line Avenue, Shreveport, Louisiana SERVICE HOTLINETEL 1-318-865-1711 FAX Parts 1-318-219-7140 FAX Tech Support Price $10.00