Manuals / Frymaster / Kitchen Appliance / Cooktop

Frymaster FBR18 Series manual 7.5Cooking Timer Control Panel Components, Item Part #

Models: FBR18 Series

1 62

Download 62 pages 63.62 Kb

Page 56

7.5Cooking Timer Control Panel Components

7.5Cooking Timer Control Panel Components

Error! Not a valid link.

ITEM PART #

1910-4496

2

810-1287

806-5339

806-5340

806-5341

806-5342

806-5343

3810-0808

4810-0807

5807-1547

6806-5260SP

COMPONENT

Cooking Timer Control Panel

Knob Assembly

Black

Gray

Red

Brown

Blue

Green

Faceplate, Timer Dial

Timer, Springwound, 60-Minute

Lamp, Red Lens, 24V Trouble

Frame, Cooking Timer Control Panel

7-5

Image 56

Frymaster FBR18 Series manual 7.5Cooking Timer Control Panel Components, Item Part #

Contents

24-HourService Hotline 819-5278FBR18 & FBRA18 Series Gas RethermalizersPage DANGER DANGERDANGER DANGERTABLE OF CONTENTS CHAPTER 2 Installation InstructionsCHAPTER 4 Preventive Maintenance CHAPTER 5 Operator TroubleshootingCHAPTER 7 Parts List 1.1Parts Ordering and Service Information 1.2Safety InformationCHAPTER 1 GENERAL INFORMATION FBR18 & FBRA18 SERIES GAS RETHERMALIZERS1.4Installation, Operating, and Service Personnel DANGER1.3Equipment Description 1.5 DefinitionsWarranty on your equipment 1.6Shipping Damage Claim ProcedureWhat to do if your equipment arrives damaged FrymasterDOES NOT ASSUME RESPONSIBILITYCHAPTER 2 INSTALLATION INSTRUCTIONS 2.1General Installation RequirementsFBR18 & FBRA18 SERIES GAS RETHERMALIZERS DANGER2.2Caster/Leg Installation 2.3Pre-ConnectionPreparations DANGERIncoming Gas Pressures DANGER 2.4Connecting to the Gas SupplyDANGER 2.5Converting to Another Gas Type DANGERCHAPTER 3 OPERATING INSTRUCTIONS 3.1Introduction3.2FBR18/FBRA18 Digital Controller FBR18 & FBRA18 SERIES GAS RETHERMALIZERS3.3Start-UpProcedure 3.4Boiling-Outthe Cookpot 3.5Shutting Down the Rethermalizer CHAPTER 4 PREVENTIVE MAINTENANCE 4.1Daily Checks and ServicesInspect Rethermalizer and Accessories for Damage Clean Cabinet Inside and Out4.2Quarterly Checks and Services 4.3Semi-AnnualChecks and ServicesClean Combustion Air Blower Check Digital Controller Set Point AccuracyCheck Burner Manifold Pressure Clean Gas Valve Vent Tubeauthorized service technician only 3.Place the gas valve in the ON position. Place the controller power switch in the ON position. When the burner lights and continues to burn, compare the indicated pressure to the table below DANGER 5.1IntroductionDANGER 5.2Troubleshooting Guides NOTE This guide applies to FBRA18 units onlyresolved ProblemNOTE This guide applies to FBRA18 units only Did water reach Has the correct setpointDid burners Page 1.Disconnect the rethermalizer from the electrical supply FBR18 & FBRA18 SERIES GAS RETHERMALIZERS CHAPTER 6 SERVICE PROCEDURES6.1Functional Description guished, current to the ignition module is cut, preventing the main valve from opening, and the igni- tion module “locks out” until the power switch is turned off and then back on TEMPERATURE PROBE WATER LEVEL SENSORS FBRA18 Only6.2Accessing the Rethermalizer for Servicing 6.3Cleaning the Gas Valve Vent Tube6.4Checking the Burner Manifold Gas Pressure 6.5Measuring Flame Current6.6.3 Replacing the Interface Board 6.6.2 Replacing the Temperature Probe6.6Replacing Components 6.6.5 Replacing an Ignitor Assembly 6.6.4 Replacing an Ignition Module6.6.7 Replacing the Gas Valve 6.6.8 Replacing a Burner Assembly6.6.6 Replacing the Combustion Air Blower 6.7Troubleshooting and Problem Isolation 6.6.9 Replacing the Cookpot6.7.1 Ignition Failures 6.7.2 Improper Burner Functioning Incoming Gas PressuresDANGER 6.7.3 Improper Temperature Control 6.8Troubleshooting Guides6.8.1 Troubleshooting the Gas Valve UNIT IS CONNECTED TO THE 24 VAC CIRCUIT IN FBR18 UNITS 24V TRANSFORMERUNIT IS CONNECTED TO POWER SUPPLY, DRAIN Is POWERVALVE IS FULLY CLOSED NO WATER IS IN POT CONTROLLER IS ONPage Page Is J1 pin grounded?THE 24VAC CIRCUIT IN FBRA18 UNITS CONTROLLER24V TRANSFORMER INTERFACE BOARD LOGIC CIRCUITRY6.8.4 Troubleshooting the Temperature Probe Probe Resistance Chart OHMSOHMS OHMS6.9Wiring Diagram for FBR18 Units 8050417DDiagram for 6.10 Wiring8051017B FBRA18 UnitsCHAPTER 7 PARTS LIST 7.1Burner System ComponentsPART # COMPONENTCOMPONENT 7.2Cabinetry and Associated ComponentsPART # ITEM PART # COMPONENTCOMPONENT 7.4Controller and Component Box AssembliesPART # COMPONENT 7.5Cooking Timer Control Panel ComponentsITEM PART # COMPONENT Cookpot, FBR18PART # COMPONENT 7.7Cookpot, FBRA18ITEM PART # COMPONENT 7.8Gas Supply ComponentsPART # COMPONENT 7.9Plumbing ComponentsPART # Page SERVICE HOTLINE