Manuals / Haier / Household Appliance / Septic System

Haier 3150 SA Contents, Models, Dimensional Drawing, Technical Data, Performance Chart, 310622L

Models: 1590 SB 3150 SA 3150 SF 1590 SA 3150 SB

1 40

Page 2

Warning	. 3	Model 1590	33
Installation	. 5	Dimensional Drawing	33
Operation	10	Technical Data	34
Maintenance	11	Performance Chart	35
Troubleshooting	14	Model 3150	36
Service	16	Dimensional Drawing	36
Pump Matrix	25	Technical Data	37
Parts	26	Performance Chart	38
Accessories	32	Graco Warranties	40
3150 Conversion Kits	32	Graco Information	40

Models

Refer to page 25 to determine the model number of your pump.

310622L

Page 2

Image 2

Contents

High Sanitation Pumps Model SA3AAA ShownInstructions/Parts List 310622L Dimensional Drawing ContentsContents Technical Data FIRE AND EXPLOSION HAZARD WarningsWarnings PRESSURIZED EQUIPMENT HAZARD BURN HAZARD PERSONAL PROTECTIVE EQUIPMENT General Information InstallationInstallation Leak Detection System Air Line Ground Wire ConnectionMountings Fluid Suction Line Fluid Outlet Line Typical InstallationFIG. 3 Typical Floor-Mount Installation FIG. 4 Orientation of Fluid Ports Changing the Orientation of the Fluid Inlet and Outlet PortsAir Exhaust Ventilation A Air supply line B Bleed-type master air valve required for pump FIG. 5 Venting Exhaust AirE Master air valve for accessories F Air line filter P Muffler C Air regulator D Air line quick disconnect Operation Pressure Relief ProcedureStarting and Adjusting the Pump Sanitizing the Pump Before First Use Maintenance MaintenanceRoutine Cleaning of Product Contact Section of Pump Lubrication Operator Preventive Maintenance ScheduleMaintenance Person Task Maintenance PROBLEM TroubleshootingTroubleshooting Follow Pressure Relief Proce Loose sanitary clamp erly/cleanly due to imbalanceLeak in inlet or outlet sanitary fit Tighten clamp Service ServiceRepairing the Air Valve Disassembly Reassembly 8. Install the valve carriage 105 so its tabs slip into the grooves on the narrow end of the actuator pis- tons 111. See FIG 3A Ball Check Assembly Check Valve Repair Flapper Check Assembly Service For Sanitary Ball Check pumps remove ball gasketSanitary Ball Check Assembly TI8769a Diaphragm Repair Tools Required diaphragm plate side high strength thread lock Sanitary Pump3A Pump shaft side Bearing and Air Gasket Removal 310622L 1590 Stainless Steel Sanitary Pumps Pump Matrix3150 Stainless Steel Sanitary Pumps Pump Matrix Sanitary Diaphragm Assembly Sanitary Ball Check Valve AssemblyFlapper Check Valve Assembly Parts Drawing Inlet and Outlet Parts List Parts ListPump Configuration Parts List Parts List Part Diaphragm Material Parts ListIndicates replacement parts † Indicates a recommended spare part 3150 Check Ball Material Parts List Indicates replacement parts † Indicates a recommended spare part Apply a medium strength thread locker to center housing boreApply medium strength adhesive to outside screw threads and torque to 130-150 in-lbs Fluid Section Parts Leak Detector and Pump Stand Parts ListAir Section Parts 3150 Conversion Kits AccessoriesAccessories 15D990 Leak Detector Model Dimensional DrawingModel TI8778a Loctite is a registered trademark of the Loctite Corporation Technical DataSantoprene is a registered trademark of the Monsanto Co Test Conditions Pump tested in water with inlet submerged Performance Chart1590 3A Performance Chart To find Fluid Outlet Pressure Flapper Check Valve Pumps 3A Ball Check Valve PumpsSanitary Ball Check Valve Pumps Model 3150 3A Performance Chart Model Graco Warranties Graco Standard Pump WarrantyExtended Product Warranty Graco Information

Contents

Contents

Model 1590

Dimensional Drawing

Technical Data

Performance Chart

Graco Warranties

3150 Conversion Kits

Graco Information

Models

310622L