97B00 | Heat Controller HTV, HTH, HTD specs

97B00

97B00???????

01-2013

Image 48

Heat Controller HTV, HTH, HTD manual 97B00

Contents

HTV/HTD/HTH Series Two-Stage Geothermal Heat Pumps To 6 Tons Table of Contents Safety General Information Horizontal Unit Location Hanger Bracket Horizontal Installation Typical Horizontal Unit Installation Field Conversion of Air Discharge Side to Back Discharge Conversion Duct System Installation Condensate Piping Horizontal Unitsರ3HU RRW Vertical Installation Vertical Unit Location Using a threaded pipe or similar device to clear May ease final drain line installationReturn Air Inlet Water Connection Installation Piping InstallationExternal Flow Controller Mounting Flushing the Earth Loop Fluid Volume gal liters per 100’ 30 meters Pipe Ground-Loop Heat Pump ApplicationsAntifreeze Antifreeze Percentages by Volume Open Loop Ground Water SystemsWater Quality Standards Pressure Tank and Pump Ground-Water Heat Pump Applications Typical Open Loop/Well Application Water Quality Standards Typical HWG Installation Hot Water Generator Installation High Water Temperature 160ºFControl Logic Error Åashes Water Tank Preparation Initial Start-UpHWG Water Piping Water Tank Reﬁll Electrical Line Voltage HT Series Electrical Data General Line Voltage Wiring Power ConnectionHWG Wiring Split Units Only Electrical Line Voltage Electrical Low Voltage Wiring Low voltage Äeld wiring for units with ECM fanLow Water Temperature Cutout Selection Thermostat Connections Accessory Connections Two-stage Units Electrical Thermostat Wiring Thermostat InstallationFault LED ATM21U01 ECM Blower Control ECM Board Tap Settings HT Units HT Series ECM Blower Performance Data CXM Controls Safety Features CXM Control Diagnostic Features Unit Operation Stat signal CXM Control Start-up OperationECM fan PSC fan Nominal resistance at various temperatures Thermostat SignalsCXM Thermostat Details Not compatible with the CXM Unit Commissioning And Operating Conditions Operating LimitsCommissioning Conditions Voltage utilization range complies with Ahri Standard Before Powering SYSTEM, please check the following Unit Start-up ProcedureUnit Start-Up and Operating Conditions Unit and System Checkout Unit Start-Up Procedure Water Temperature Change Through Heat Exchanger Unit Operating ConditionsHT Coax Water Pressure Drop Antifreeze Correction Table HT Series Typical Unit Operating Pressures and Temperatures Psig GPM Performance Data HT 024 Full Load Cooling EAT 80/67F Performance Data HT 036 Full Load Performance Data HT 048 Full Load Performance Data HT 060 Full Load Performance Data HT 070 Full Load Preventive Maintenance Troubleshooting CXM Functional Troubleshooting Flow Chart CXM Process Flow Chart Functional Troubleshooting Main power problems Performance Troubleshooting Performance Troubleshooting Htg Clg Possible Cause Solution Troubleshooting Form +&$ 97B00