Multiquip DA700SSW, DA7000WGH manual Components Engine, Initial Servicing

COMPONENTS (ENGINE)

Figure 5. Kubota Z482 Series

INITIAL SERVICING

The engine (Figure 5) must be checked for proper lubrication and filled with fuel prior to operation. Refer to the manufacturer's engine manual for instructions and details of operation and servicing.

1.Water Drain Cock — Open this cock to drain water

2.Fuel Filter — Prevents dirt and other debris from entering the fuel system.Replace filter as recommended in the maintenance section of this manual.

3.Fuel Feed Pump — Pumps fuel to the injection system.

4.Oil Dip Stick/Gauge — Remove to check amount and condition of oil in crankcase. Refill or replace with recommended type oil as listed in Table 5.

5.Speed Control Lever — Controls engine speed. This lever is factory set. DO NOT adjust this lever.

6.Injector Pump — Provides fuel under pressure to the injector nozzles.

7.Air Filter — Prevents dirt and other debris from entering the fuel system. Loosen clips on side of air filter cannister to gain access to filter element. Replace with only manufactures recommended type air cleaner.

8.Cooling Fan Blades — Make sure cooling fan blades are not bent or broken. A damaged fan blade can cause the engine to run hot and overheat.

9.Fan V-Belt— ALWAYS make sure V-belt is properly tensioned. A loose or defective V-belt can adversely affect the performance of the generator.

10.Oil Drain Plug/Crankcase — Remove to drain crankcase oil. Fill with recommended type oil as listed in Table 5. Crankcase holds a maximum of 2.64 quarts (2.5 liters) of motor oil.

11.Starter — Starts engine when ignition key is rotated to the "ON" position

12.Oil Filter — Spin-on type, fi lters oil contaminants. Replace filter as recommended in the maintenance section of this manual.

13.Oil Pressure Switch — Monitors engine oil pressure. In the event of low oil pressure engine will shutdown.

14.Alternator — Provides power to the +12VDC electrical system. Replace with only manufactures recommended type alternator.

15.Oil Filler Cap — Fill with recommended type oil as listed in Table 5.

DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 21