Multiquip DA7000WGH, DA700SSW manual Nameplate and Decals Assy, 30A

NAMEPLATE AND DECALS ASSY.

26

FUSE PULLY

USE SPECIFIEDFUSEONLY.	F6		SPARE 15A 5A30A
	F1	30A
	F5	15A
	F4	5A
	F3	5A
	F2	5A

17

23

WARNING!

Before connecting this generator to any building’s electrical system, a licensed electrician must install an isolation [transfer] switch.

Serious injury or death may result without this transfer switch.

	OPERATING PROCEDURE
	MULTIQUIP WhisperWatt
	AC Generator
1.	Check the oil level.
2.	Check the water level.	9. Let the engine idle for more than 5 minutes
3.	Check the fuel level.		with the Idle Control switch in “ON” position.
4.	Turn the Idle Control switch to “ON”.	10. Check the engine for abnormal vibrations noise
5.	Insert the key into the Starter Switch.		and oil leakage.
6.	Turn the key to “RUN”. The Charge	11. Turn the Idle Control switch to either “ON” or
			“OFF” for full engine operation.
	Warning lamp and the Oil Pressure Warning lamp12. After generating let the engine run for 5 minutes
	should be lit.		with the Idle Control switch in the “ON” position.
7.	Turn the key to “HEAT”. When the preheat lamp		NEVER STOP THE ENGINE SUDDENLY EXCEPT
	lights turn the key to “START” to start the engine.		IN AN EMERGENCY.
	AVOID HIGH SPEEDS IMMEDIATELY AFTER	13. Stop the engine by turning the key in the
	STARTING.		Starter Switch to “STOP” and remove the key.

8.When the engine starts, the Oil Pressure Alarm lamp should go out.

CHECK DAILY

1.Maintain water/coolant level at top of radiator coils.

2.Maintain reserve tank water/ coolant level between H and L mark. Use a mixture of 50/50 Anti-Freeze/Water.

3.Add coolant when reserve tank is low (L). Fill to the H mark with Anti-Freeze/Water.

CAUTION

WATER

COOLANT

LEVEL

H	RESERVE
L	TANK

DCL194

10

16

20A	25A	25A	25A
120V			120V/240V

AC POWER OUTPUT

A55200000A

DANGER
THE POSSIBILITY EXISTS OF ELECTROCUTION IF	34
GENERATOR/WELDER IS NOT PROPERLY GROUNDED.
ALWAYS CONNECT EARTH GROUND (GROUND
ROD) TO GENERATOR G.F.C.I. GROUND TERMINAL.

WHISPERWATT
7KW AC
Model
	DA-7000SS
				ON
			IDLE	OFF
		AC VOL		CONTROL
	AC CIRCUIT
		TMETER
	BREAKER		00
7000	WATT			000
			HOURS
DIESEL			HOUR METER
	POWERED AC	GENERATOR

STOP	RUN
	HEAT

START

STARTER SWITCH

30

33

GROUND

22

CABLE

GGENE

#8 MINIMUM

ROUNRADTOR

G.F.C.I

LUG

GROUND ROD

13

GROUND

G.F.

STUD

GROUND

FOR EARTH

C.I.

CONNECT TO

BUILDING

D92200100

GROUND

G.F.

(OPTION)

C.I.

27

D92200100

GROUNDfor

FOR FURTHER GROUNDING

INSTRUCTIONS, READ MANUAL

8 FT. MINIMUM

REFERENCE

G.F.C.I

NEC 250-52(C)

S-3821

D93110000

22

9

DANGER

Using a generator indoors CAN KILL YOU IN MINUTES.

Do not

DANGER

S-20

91

ELECTRICAL

internaltouch output

terminals

Turn

wiring

or

Generator exhaust contains carbon monoxide. This is

1

SHOCK

off while unit is

HAZARD

install,qualified

before servicing.

Only

power

operating.

a posion you cannot see or smell

use or

personnel

equipment.

service thisshould

.

G

15

MODEL NO

SERIAL

ROUND

NEVER use inside a home

Only use OUTSIDE and

far away from windows,

or garage, even if doors

S-1123

doors, and vents.

and windows are open

Avoid other generator hazards.

FUEL

36

READ MANUAL BEFORE USE.

DRAIN

11

S-

35

3060

DANGER EXPLOSIVE GASES

FUEL COCK

ON

ON

5

8

CAUTION

OIL LEVEL

DIPSTICK

Before starting the engine, check that the oil

H

25

S-2090

level is within the indicated operating range.

If the level is above the H mark or below

the L mark, it is important to correct before

L

operating to avoid damage to the engine.

S-14

04

DRAIN

COOLANT

S-1

40

3

3

DRAIN

OIL

R

E

CAUTION

C

LE

M

E

RS

E

PLA

R

E

LE

U

HO

-1406

P

ER

S

PA

Y

100

EV

ER

2

4

FRONT VIEW

12	COOLING
	WATER

S-3061

20

WARNING

HOT COOLANT can cause severe burns.

DO NOT remove cap if radiator is hot.

DCL183

28

37

DECAL

KIT

	DIESEL	ONL	Y		WATER
#2	FUEL			COOLING
USE
		ON
				ON

REAR VIEW

Cigarettes, flames or sparks could cause battery to explode. Always shield eyes and face from battery. Do not charge or use booster cables or adjust post connections without proper instruction and training.

24	KEEP VENT CAPS TIGHT AND LEVEL
	POISON CAUSES SEVERE BURNS
	Contains sulfuric acid. Avoid contact with skin, eyes or clothing. In		WARNING
	KEEP OUT OF REACH OF CHILDREN
	event of accident flush with water and call a physician immediately.
			Only operate machine in well ventilated
			areas.
			DO NOT inhale exhaust gases.
	6		S-4984	14
			Only qualified personnel should
		DANGEROUS	install, use or service this
		GAS	equipment.

USE #2 DIESEL	WARNING
FUEL ONLY	MOVING PARTS can cause		19
	severe injury.
	DO NOT operate with
S-1408	doors open.
	Stop engine before
	servicing.	DCL182

CAUTION

HOT PARTS can burn skin.

DO NOT touch until the machine has sufficiently cooled.

DCL181

29

	TM	7000
WHISPERWATT		32
	31
7
CAUTIONNOT
DO	WITH
OPERATE	OPEN
DOORS

18

PAGE 62 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11)