Manuals / Multiquip / Lawn and Garden / Portable Generator

Multiquip DCA-100SSJU operation manual Rules For Safe Operation, Table of Contents

Models: DCA-100SSJU

1 92

Download 92 pages 52.01 Kb

Page 7

RULES FOR SAFE OPERATION

Table of Contents

RULES FOR SAFE OPERATION

CAUTION:

■NEVER touch output terminals during operation. This is extremely dangerous. Always stop the machine when contact with the output terminals is required.

CAUTION:

CAUTION:

DO NOT touch or open any of the below mentioned components while the generator is running. Always allow sufficient time for the engine and generator to cool before performing maintenance.

Radiator

1.Radiator Cap - Removing the radiator cap while the engine is hot will result in high pressurized, boiling water to gush out of the radiator, causing severe scalding to any persons in the general area of the generator.

■Backfeed to a utility system can cause electrocution and.or property damage. Do not connect to any building's electrical system except through an approved device or after building main switch is opened.

CAUTION:

■Never use damaged or worn cables when connecting power tools or equipment to the generator. Make sure power connecting cables are securely connected to the generator’s output terminals, insufficient tightening of the terminal connections may cause damage to the generator and electrical shock.

2.Coolant Drain Plug - Removing the coolant drain plug while the engine is hot will result in hot coolant to gush out of the coolant drain plug, therefore causing severe scalding to any persons in the general area of the generator.

3.Engine Oil Drain Plug - Removing the engine oil drain plug while the engine is hot will result in hot oil to gush out of the oil drain plug, therefore causing severe scalding to any persons in the general area of the generator.

DCA-100SSJU — PARTS AND OPERATION MANUAL(STD)— REV. #2 (05/03/01) — PAGE 7

Image 7

Multiquip DCA-100SSJU operation manual Rules For Safe Operation, Table of Contents

Contents

PARTS AND OPERATION MANUAL MQ POWER DCA-100SSJU WHISPERWATTTM GENERATORTable of Contents StandardTable of Contents Table of Contents HERES HOW TO GET HELPMAIN 800/421-1244or 310/537-3700FAX: 310/537-3927MQ POWER DCA-100SSJU AC GENERATOR TABLE OF CONTENTSExtra PARTS ORDERING PROCEDURESNow! Direct TOLL-FREEaccess • • • • • •Table of Contents RULES FOR SAFE OPERATIONGENERAL SAFETY Table of Contents RULES FOR SAFE OPERATIONLoading and Unloading Crane Table of ContentsBattery RULES FOR SAFE OPERATIONTransporting RULES FOR SAFE OPERATIONTable of Contents Maintenance SafetyTable of Contents DCA-100SSJU— TOWING RULES FOR SAFE OPERATIONTowing Safety Precautions Table of Contents DCA-100SSJU —TRAILER-SAFETYGUIDELINESExplanation of Chart MODEL DCA-100SSJU —TRAILER-SPECIFICATIONSTable of Contents Table 1. SpecificationsMODEL DCA-100SSJU —TRAILER-SPECIFICATIONSTable of Contents Table 1. Specifications ContBrakes DCA-100SSJU— TRAILER BRAKING SYSTEMTable of Contents Electric Brake AdjustmentFigure 2. Electrical Brake Components DCA-100SSJU —TRAILERBRAKING SYSTEMTable of Contents Hydraulic/Air/Surge BrakesTire Wear/Inflation DCA-100SSJU— TRAILER TIRES & SUSPENSIONTable of Contents Tires/Wheels/Lug NutsLug Nut Torque Requirements DCA-100SSJU— TRAILER TIRES & SUSPENSIONTable of Contents Table 3. Suspension Torque RequirementsTable of Contents DCA-100SSJU —TRAILERWIRINGDIAGRAMSLIGHTS ARE ORIENTED FROM THE DRIVER’S SEAT SYMPTOM DCA-100SSJU —TRAILER-BRAKETROUBLESHOOTINGTable of Contents Table 5. Electric Brake TroubleshootingSymptom DCA-100SSJU —TRAILER-BRAKETROUBLESHOOTINGTable of Contents Table 6. Hydraulic Brake TroubleshootingTable of Contents DCA-100SSJU— GENERATOR DECALSTable of Contents DCA-100SSJU— GENERATOR DECALSEngine Specifications DCA-100SSJU— SPECIFICATIONSTable of Contents Generator SpecificationsEngine Operating Panel DCA-100SSJU— GENERAL INFORMATIONTable of Contents DCA-100SSJUFAMILIARIZATION GeneratorTable of Contents DCA-100SSJU— MAJOR COMPONENTSFigure 6. Major Components Table of Contents DCA-100SSJU— DIMENSIONS TOP, SIDE AND FRONTFigure 7. Dimensions NOTE PAGE Table of Contents DCA-100SSJU— CONTROL PANELFigure 8. Control Panel Table of Contents DCA-100SSJU— CONTROL PANELTable of Contents DCA-100SSJU— ENGINE OPERATING PANEL WITH KEYFigure 9. Engine Operating Panel Table of Contents DCA-100SSJU— ENGINE OPERATING PANEL WITH KEYTable of Contents DCA-100SSJU— ENGINE OPERATING PANEL WITH MPECFigure 10. Engine Operating Panel Table of Contents DCA-100SSJU— ENGINE OPERATING PANEL WITH MPECFIGURE 13. Output Terminal Cover DCA-100SSJU— OUTPUT TERMINAL PANEL OVERVIEWTable of Contents FIGURE 15. Connecting LoadLegs O and Ground are considered Bonded Grounds DCA-100SSJU— OUTPUT TERMINAL PANEL OVERVIEWTable of Contents FIGURE 16. Output Terminal PanelPower DCA-100SSJU— OUTPUTTERMINAL PANEL OVERVIEWTable of Contents Power in UsePosition Table of ContentsFIGURE 18. AC Voltmeter Change-overswitch DCA-100SSJU— OUTPUT TERMINAL PANEL OVERVIEWFIGURE 23. Hard Wire Hookup at 240/120V Position Table of Contents240/120V Hard Wire Hookup 480/240V Hard Wire HookupSingle Phase: 277V, 254V, or Table of ContentsSingle Phase: 480V, 440V, or 416 Volt 3 Phase, 480V, 440V, or 416 VoltSingle Phase: 139V, 127V, or Table of ContentsSingle Phase: 240V, 220V, or 208 Volt 3 Phase, 240V, 220V, or 208 VoltDCA-100SSJU— OUTPUT TERMINAL PANEL OVERVIEW Table of ContentsSingle Phase: 120 Volt Single Phase, 240 VoltIndoor Installation DCA-100SSJU— INSTALLATIONTable of Contents Outdoor InstallationTable of Contents DCA-100SSJU— INSTALLATIONTable of Contents DCA-100SSJU— PRE-SETUPTable 12. Recommended Motor Oil DCA-100SSJU— PRE-SETUPTable of Contents Air Cleaner DCA-100SSJU— PRE-SETUPTable of Contents Cleaning the RadiatorWiring DCA-100SSJU— PRE-SETUPTable of Contents Battery Cable InstallationTable 15. Power Factor By Load DCA-100SSJU— LOAD APPLICATIONTable of Contents Single Phase LoadBefore Starting Generator and Control Panel DCA-100SSJU— GENERATOR START-UPPROCEDURETable of Contents Before Starting EngineTable of Contents DCA-100SSJU— GENERATOR START-UPPROCEDURE MANUALFigure 58. Voltage Adjust Control Knob DCA-100SSJU— GENERATOR START-UPPROCEDURE MANUALTable of Contents Figure 57. Engine Speed Switch lowTable of Contents DCA-100SSJU— GENERATOR START-UPPROCEDURE AUTOTable of Contents DCA-100SSJU— GENERATOR SHUTDOWN PROCEDUREENGINE SHUTDOWN Table of Contents DCA-100SSJU— MAINTENANCETABLE DCA-100SSJU— MAINTENANCETable of Contents INSPECTION / MAINTENANCETable of Contents DCA-100SSJU —TROUBLESHOOTINGENGINETABLE 17. ENGINE TROUBLESHOOTING SYMPTOM DCA-100SSJU —TROUBLESHOOTINGENGINETable of Contents TABLE 18. ENGINE TROUBLESHOOTING CONTINUEDTable of Contents DCA-100SSJU —TROUBLESHOOTINGGENERATOR/ENGINETABLE 19. ENGINE & GENERATOR TROUBLESHOOTING Solution DCA-100SSJU— TROUBLESHOOTING MPECTable of Contents TABLE 20. MPEC TROUBLESHOOTINGItems Found In the “Items Number” Column EXPLANATION OF CODE IN REMARKS COLUMNTable of Contents Items Found In the “Remarks” ColumnTable of Contents DCA-100SSJU— SUGGESTED SPARE PARTSDescription Table of Contents DCA-100SSJU ---GENERATOR ASSYGENERATOR ASSY Table of Contents GeneratorDCA-100SSJU GENERATOR ASSYTable of Contents DCA-100SSJU ---CONTROL BOX ASSYCONTROL BOX ASSY DCA-100SSJU Control BoxCONTROL BOX ASSY Table of ContentsTable of Contents DCA-100SSJU ---CONTROL BOX ASSYCONTROL BOX ASSY Table of ContentsControl Box DCA-100SSJUTable of Contents DCA-100SSJUENGINE AND RADIATOR ASSYENGINE AND RADIATOR ASSY Engine and Radiator Table of ContentsDCA-100SSJUENGINE AND RADIATOR ASSY Table of Contents DCA-100SSJUENGINE AND RADIATOR ASSYPART NO Table of ContentsEngine and Radiator DCA-100SSJUENGINE AND RADIATOR ASSYTable of Contents DCA-100SSJU ---ENGINE OPERATING PANEL ASSYS/N 700001 TO S/N 7400296~ Engine Operating Panel Table of ContentsDCA-100SSJU ENGINE OPERATING PANEL ASSYTable of Contents DCA-100SSJU ---OUTPUT TERMINAL ASSYOUTPUT TERMINAL ASSY DCA-100SSJU Output TerminalOUTPUT TERMINAL ASSY Table of ContentsTable of Contents DCA-100SSJU ---BATTERY ASSYBATTERY ASSY DCA-100SSJU Table of ContentsBattery BATTERY ASSYTable of Contents DCA-100SSJU ---MUFFLER ASSYTable of Contents DCA-100SSJUMUFFLER ASSYMuffler Table of Contents DCA-100SSJU ---FUEL TANK ASSYFUEL TANK ASSY FUEL TANK ASSY Fuel TankTable of Contents DCA-100SSJUTable of Contents DCA-100SSJU ---ENCLOSURE ASSYENCLOSURE ASSY DCA-100SSJU EnclosureENCLOSURE ASSY Table of ContentsDCA-100SSJU ---ENCLOSURE ASSY Table of ContentsENCLOSURE ASSY Table of ContentsEnclosure DCA-100SSJUTable of Contents DCA-100SSJU ---RUBBER SEAL ASSYRUBBER SEAL ASSY DCA-100SSJU ---RUBBER SEAL ASSY Rubber SealTable of Contents Table of Contents DCA-100SSJU ---DECALSDECAL ASSY DCA-100SSJU DecalDECALS Table of ContentsTERMS AND CONDITIONS OF SALE — PARTS Effective: July 1,Table of Contents SPECIAL EXPEDITING SERVICENOTE PAGE Table of Contents ON-HANDWHEN CALLINGPLEASE HAVE THE MODEL AND SERIAL NUMBER HERES HOW TO GET HELP