Vermont Casting SDDVRCCH, SDDVRCMB manual Stardance Direct Vent - Rear Vent Gas Heaters, 20012950

Stardance Direct Vent - Rear Vent Gas Heaters

Table of Contents

PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS BEFORE USING APPLIANCE.

Thank you and congratulations on your purchase of a Vermont Castings stove.

IMPORTANT: Read all instructions and warnings carefully before starting installation. Failure to follow these instructions may result in a possible fire hazard and will void the warranty.

Installation &	General Information	3
Operating	Requirements for the Commonwealth of Massachusetts	4
Instructions	Stove Dimensions	5
	Installation Requirements	6
	Locating the Stove	6
	Clearance Requirements	6
	Parallel Installation: Minimum Clearance and Flue Centerline	7
	Corner Installation: Minimum Clearance and Flue Centerline	7
	Wall and Ceiling Clearances	7
	Mantel Clearances	7
	Hearth Requirements	7
	Gas Specifications	8
	Gas Inlet and Manifold Pressures	8
	High Elevations	8
	Horizontal Termination	8
	Vertical Termination	9
	Restrictor Plate Adjustment for Extended Pipe Runs	9
	Vent Termination Clearances	10
	General Venting Information - Termination Location	11
	Termination Clearances	12
	Vent Components	13
Installation	Install Optional FK28 Fan Kit	14
	Venting System Assembly	15
	Rear Vent	15
	Through Side Wall / Vent Termination Below Grade	16
	Side Wall Termination Assembly	16
	Vent Termination Below Grade	18
	Vertical (Through the Roof) Vent Assembly	19
	Vertical Through Existing Chimney	19
	Fireplace Vent Termination Clearances	19
	Fireplace Installation Requirements	21
	Selkirk Direct-Temp Metalbestos Direct Vent System	22
	Connect Gas Supply Line	27
	Burner Information	27
	Complete the Assembly	27
	Install ON/OFF Switch (R Models Only)	27
	Install the Front Plate	28
	Thermostat Connection	28
	Install the Log Set	29
Operation	Operable Doors	31
	Your First Fire	31
	Pilot and Burner Inspection	31
	Flame & Temperature Adjustment	31
	Flame Characteristics	32
	Lighting and Operating Instructions	33
	Troubleshooting	34
	Instructions for RF Comfort Control Valve	35
	Fuel Conversion Instructions	39
Maintenance	Annual System Inspection	43
	Logset and Burner Cleaning	43
	Care of Cast Iron	43
	Cleaning the Glass	43
	Glass Replacement	43
	Gasket Replacement	44
	Inspect the Vent System Annually	44
	Check the Gas Flame Regularly	44
	Stove Disassembly	44
	Wiring Diagrams	44
Replacement Parts 46
Optional Accessories		49
Warranty	....................................................................................................................................................	51
Energuide	....................................................................................................................................................	52

2 20012950