E

EJU00595

TROUBLESHOOTING

If any trouble happens on your water vehicle, use this section to check for the possible case.

If you can not find the cause, or if the procedure for replacement or repair is not described on this owner’s manual, ask your Yamaha Water Vehicle dealer or qualified mechanic for the proper service.

The trouble shooting chart contains “TROUBLE”, “POSSIBLE CAUSE”, “REMEDY”, “REFER PAGE”.

Check the possible cause and remedy, and also the referred page for the maintenance steps, to solve the trouble.

EJU00596a

TROUBLESHOOTING CHART

TROUBLE

POSSIBLE CAUSE

REMEDY

Refer Page

The engine does not

Starter motor does not turn over

 

 

start

8Multifunction

“LOCK” mode is selected

8Select “START” mode

2-15

 

meter

 

 

 

 

 

 

 

 

 

 

 

 

8Stop switch

Lock plate is not in place

Install lock plate

2-7

 

 

 

 

 

 

8Fuse

Burned out

8Replace the fuse and

4-23

 

 

Check wiring

 

 

 

 

 

 

 

Run down

8Recharge

4-20

 

 

 

 

 

 

8Battery

Poor terminal connections

8Tighten as required

4-21

 

 

 

 

 

 

 

Terminal is eroded

8Clean

—

 

 

 

 

 

 

8Starter

Faulty

8Have a service at

—

 

component

 

Yamaha dealer

 

 

 

 

 

 

Starter motor turns over

 

 

 

 

 

 

 

 

8Fuel cock

“OFF” position

8Turn the fuel cock to

2-6

 

 

“ON”

 

 

 

 

 

 

 

Empty

8Refill as soon as

3-1

 

8Fuel

 

possible*1

 

 

 

 

 

Stale or contaminated

8Have service at

4-10

 

 

 

 

 

Yamaha dealer

 

 

 

 

 

 

 

Water or dust collected

8Have service at

4-10

 

8Fuel tank

 

Yamaha dealer

 

 

 

 

 

Built-up pressure

8Open the fuel tank filler

2-6

 

 

 

 

 

cap and release pressure

 

 

 

 

 

 

8Spark Plug

Fouled or defective

8Clean or Replace

4-15

 

 

 

 

 

 

8Spark Plug cap

Not fitted or loose

8Fit properly

4-15

 

 

 

 

 

 

8Crankcase

Filled with water

8Crank engine with plug

5-7

 

 

out until clean

 

 

 

 

 

 

8Fuel filter

Clogged or water collected

8Have service at

4-11

 

 

Yamaha dealer

 

 

 

 

 

 

8Choke

Knob automatically return

8Tighten the choke cable

4-19

 

 

tension adjust nut

 

 

 

 

 

 

 

 

 

*1 : Turn the fuel cock to “RES (reserve)” to return to shore.

5-1