Carrier 69UG15 manual Customer Specific Control Panel and Box

Page 15

CONTROL		CONTROL
PANEL		BOX
2	3		11
1		10
1	4
	4
	5	9	12
		9
	6
	7	8
			13

1.	Total Time Meter	8.	Ground Studs
2.	Water Temperature Gauge	9.	Safety Relay
3.	Oil Pressure Gauge	10.	Intake Heater Relay
4.	Ammeter	11.	Intake Heater Timer
5.	Intake Air Heater Switch	12.	Circuit Breaker (CB2)
6.	Ignition Switch	13.	Circuit Breaker (CB3)

7.Battery Charger Fuse or Circuit Breaker (CB5)

Figure 1-7 Customer Specific Control Panel and Box

CONTROL		CONTROL
PANEL	4	BOX
	4
3	5	13	14
		13	14
2
1	6	12
1		12	15
			15
	7		16
		11	16
	8
	9	10
	9

1.	Total Time Meter	9.	Battery Charger Fuse
2.	Engine Start Alarm (Buzzer)		or Circuit Breaker (CB5)
3.	Water Temperature Gauge	10.	Ground Studs
4.	Auto Restart Module	11.	Circuit Breaker (CB2)
5.	Oil Pressure Gauge	12.	Starter Relay (SR)
6.	Ammeter	13.	Low Coolant Relay (LR)
7.	Engine Start/Intake Heater	14.	Intake Heater Relay (HR)
	Energized Light	15.	Safety Relay (S)
8.	Ignition Switch	16.	Circuit Breaker (CB3)
	Figure 1-8 Auto Restart Control Box and Panel
T-343		1--8

Image 15

Contents Operation and Service Model 69UG15 Table of Contents Table of Contents List of Illustrations List of TablesTable Number Safety Summary Specific Warning and Caution Statements Configuration Identification Section DescriptionIntroduction PID Generator Set Volt343 Engine Screw Threads EngineControl Panel and Related Components a. Gauges and Senders Battery ChargerOperating Controls and Instruments IntroductionManual Switches Safety DevicesMeters Customer Specific Control Panel and Box Fuel Auto Restart Preset Values Indicator DescriptionAuto Restart Sequencing Intake Engine SeriesAuto Restart Sequencing Intake Engine Series Nominal Tank Sizes Fill Capacity Draw Capacity Unit SpecificationsIntake Heater GeneratorWinter Summer Outdoor Temperature CentigradeEngine Data SAEOperation Generator SET InstallationGenerator SET Removal Typical Generator Set Mounting Quick MountCold Engine Preheat Times Starting and Stopping InstructionsControl Circuit Operation Engine Will Not Start Section TroubleshootingRemedy Condition Possible Cause Reference Section Diesel EngineMalfunction In The Engine Starting Circuit Condition Possible Cause Reference SectionEngine Will Not Shut Off Starter Motor MalfunctionBattery Charger Solid State Miscellaneous Engine TroubleshootingAlternating Current Generator Auto RE-START Option Remedy Section Service and Preventive Maintenance Preventative Maintenance ScheduleBattery Service 1000 Interval Units Description of ProcedureUnits EveryHours Interval UnitsServicing Heater Switch 1. Remove control box cover Servicing Low Oil Pressure SwitchAttempt to Adjust Engine Speed Cooling Preventative Maintenance and Operating PrecautionsEngine Crankcase Breather Servicing the Alternating Current GeneratorRotor Damage Terminal Strip CleaningWinding Insulation Testing Wire OhmDiode Testing Bearing ReplacementTerminals see Figure Bolt Isolator Truss Frame UnidriveEngine Isolator/Shockmount Replacement Generator Install Mount With Large Flare AT TOP FrameBolt Shockmount Unidrive Torque Requirements Engine & Generator SHOCKMOUNTS/ISOLATORS TOP ViewEngine Mount Right Side View Schematic Diagram Legend Section SchematicsSchematic Diagram Schematic Diagram 460 Volt Alternating Current Generator Schematic Diagram 230 Volt Alternating Current Generator Based On Drawing 62-11413-00 Rev a Schematic Diagram Schematic Diagram 460 Volt Alternating Current Generator Index Index