MasterCraft 2009 MariStar X-Series owner manual Service log, Every 100 Hours Date

Page 83

service log

	As Needed	Date	Date	Date	Date
	Replace raw water impeller
	Add/change oil and filter

	Replace battery


	Every 50 Hours	Date	Date	Date	Date
	Lubricate starter gear & shaft

	Change engine oil & filter
	Check all safety equipment


	Every 100 Hours	Date	Date	Date	Date
	Clean flame arrestor
	Replace water impeller
	Engine tune-up
	Change transmission fluid
	Check engine mounts
	Check prop shaft coupling alignment

	Inspect exhaust flaps

	Lubricate steering system

	Lubricate shift & throttle system

	Check/replace ballast pump impeller
	Inspect complete fuel system

	Change fuel filter

MasterCraft 2009 Owner’s Manual - Page 23-1

Image 83

Contents 2009 MasterCraft Welcome aboard Page 2-1 Page 16-2, 16-5, Page Table of contents General Precautions Boating safetyRecommended Equipment Safety EquipmentSafety Afloat Required EquipmentSkiing and Wakeboarding Safety Operator’s License Common sense approach Rules of the open water Fishing Vessel Right-of-Way OvertakingOther Special Situations Sailing Vessel Right-of-WayGuide to individual models Exhaust Bow Light Transom Drain Plug MariStar Fuel Tank Engine Batteries Filler Star CSX Instrument panels Measurements Volt Receptacle Accessory SwitchesAft Light Switch All Models-Actual Switch Usage Will VaryMariStar 230, X-30, MariStar 245 MariStar 280 Attitude Adjustment or Trim Tab SwitchCircuit Breakers Ballast Empty/Fill SwitchesManual and Automatic Bilge Pump Switch Manual Blower SwitchDual Battery Operation Switch Clock Adjustment SwitchCourtesy Lights Switch Display Selector SwitchMariStar 280/X-80, CSX-220, CSX-265 Engine Hatch SwitchEngine Synchronizing Switch Engine Oil Pressure GaugeFuel Gauge Heater SwitchInstrument Panel Gauge Backlighting Switch Low Voltage Battery AlarmSeat Heat Switches Navigation/Anchor Lights SwitchOther Alarms Refrigerator SwitchShift/Throttle Control Shower and/or Slick Boot SwitchSink Switch Temperature GaugeVideo Display Gauge Tower Lights SwitchPage Voltmeter Wash Down SwitchWhat Type of Gasoline To Use Using care when fuelingFuels Outside United States and Canada When the Boat Is Not Used for a WhileUsing Oxygenated Fuels or Fuels with Alcohol When Fuel Runs Out or Too Low for Proper OperationPage After Operation Safety checks and servicesBefore Each Operation During OperationAfter Break-In New boat break-inFirst Hours of Operation Page Shifting Gears Before StartingStarting the Engine Stopping UnderwayOperational hints Page Docking and Tie-Up Unusual Operating ConditionsStorage Cradle Using Lifting EyesUsing Lifting Slings Lifting the boatStainless Steel and Chrome Corrosion preventionMarine Growth Galvanic CorrosionUpholstery Cleaning the boatHull Windshield CarpetTeak Wood Fiberglass Swim PlatformEnclosed Head Slick BootAcceptable Upholstery Cleaners Unacceptable Upholstery CleanersApco Mastercraft boat care products MasterCraft Marine Motor Oil & Filters MasterCraft Cleaning & Detailing KitMasterCraft Microfiber Detailing Cloths After Each Use Frequency and Scheduled MaintenanceNew Boat Break-In Before Each UseAnnually Every One Hundred 100 Hours Quarterly Every Fifty 50 HoursInspect the Battery Connections and Hold-Downs Check Raw Water Intake Strainer where equippedInspect the Propeller Shaft Log for Water Entry By the warrantyInspect the Exhaust System for Leaks Inspect the Fuel System for LeaksGeneral Cleaning and Storage Check That the Battery Is Fully ChargedCheck the Engine Mounts Lubricate the Engine Starter Gear and ShaftLubricate the Steering System Check the Propeller Shaft Coupling AlignmentInspect the Exhaust Flaps for Damage Inspect the Complete Fuel System for Leakage Lubricate the Shift and Throttle SystemCheck the Ballast Pump Impeller Fire Extinguisher and Suppression Units Fuel System Treatment General Power Package PreparationGeneral Preparation Other Winterization Preparations Re-Activating the Boat After Storage Ballast System PreparationsChanging Propellers Checking/Repairing PropellersAnchor and Windlass Battery ChargerComfort and convenience Fire Suppression and Extinguishing CoolersHead GPS and ChartplotterBefore operation HeaterRefrigeration Hydraulic Steering SystemLighting Livewell/Kill Box/Catch BoxShower or Wash Down Seat HeatersStereo Equipment Swim/Boarding PlatformsFolding Down the Platform TablesWater Heater TowersVideo Screen Guide to troubleshooting Limited warranty statement Page Page Page Warranty Registration Transfer Warranty registration and transferEvery 100 Hours Date Service log12-1 IndexGauge, Voltmeter Gauges & Switches, Variations Platforms, Swim/Boarding 19-7 Storage & Winterization 17-1 19-9 Transfer, Warranty Registration 22-1 ProStar MariStar Series Saltwater Series