Ducane 3400 owner manual Gas Leak Checks, Re-install Control Panel

Page 18

CONNECTION Liquid Propane Gas Grills

WARNING: An LP (propane) tank is overfilled if it contains more than 80% by weight of its total capacity of propane (LP). An incorrectly filled or an overfilled LP (propane) tank can be dangerous. If this information is not followed exactly, a fire causing death or serious injury may occur. If a tank is overfilled and the weather causes the warming of the LP tank, (a hot day, tank left in sun or stored indoors) internal pressure is created due to expansion of the propane which in turn causes the LP gas to be released through the pres- sure relief valve on the tank. The pressure relief valve is a safety device required on 20 lb. propane tanks by the Depart- ment of Transportation to prevent a catastrophic tank failure due to excessive pressure. LP gas released from the tank is flammable and can be explosive.

Gas Leak Checks

Remove Control Panel for Leak Testing

1.Remove control knobs.

2.Remove the two (2) screws and washers holding each valve to the control panel and control knob bezel.

3.Loosen the control panel by removing two (2) screws from each side of the front control panel.

4.Pull control panel away from grill.

Never use a match or flame for leak detection. Use soapy water or testing solution. Brush the solution onto connection points and look closely for bubbles indicating escaping gas. If leaks are detected, shut off the main gas supply valve and securely retighten connections, then repeat the leak test.

On cabinet models, perform this operation before placing the tank into its storage compartment. After placing the tank in the compartment, recheck the tank to see if any connections were disturbed.

WARNING: Never use an open flame when testing for gas leaks. Use of an open flame may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.

Check:

 

1)

Side burner hose to side burner valve.

 

2)

Gas supply hose-to-manifold connection.

 

 

WARNING: If there is a leak at connection (1) or (2), retighten

 

 

the fitting with a wrench and recheck for leaks with soap and

 

 

water solution. If a leak persists after retightening the fitting,

 

 

turn off the gas. DO NOT OPERATE THE GRILL. Contact the

 

 

Customer Service Representative in your area by calling

 

 

1-800-382-2637.

 

3)

Regulator-to-Cylinder connection.

 

4)

The hose-to-regulator connection.

 

5)

Valves-to-manifold connections.

 

 

WARNING: If there is a leak at connections (3), (4) or (5),

 

 

turn off the gas. DO NOT OPERATE THE GRILL. Contact the

 

 

Customer Service Representative in your area by calling

 

 

1-800-382-2637.

 

When leak checks are complete, turn gas supply OFF at the source and rinse

 

connections with water.

 

Re-install Control Panel

 

Follow ‘Remove Control Panel’ steps in reverse. Make sure all screws are secure.

 

18

www.ducane.com

Page 17 Page 19
Image 18
Page 17 Page 19
Contents 3400 Wash hands after handling this product Liquid Propane GAS Units onlyWARRANTY, GARANTÍA, Garantie Five-Year Limited WarrantyParts LIST, Lista DE PIEZAS, Liste DES Piéces ASSEMBLY, ENSAMBLAJE, Assemblage Front Frente Avant 3400 4400 3400 4400 ASSEMBLY, ENSAMBLAJE, Assemblage ASSEMBLY, ENSAMBLAJE, Assemblage 3400 3400 4400 ASSEMBLY, ENSAMBLAJE, Assemblage ASSEMBLY, ENSAMBLAJE, Assemblage California Proposition Safety InformationAssembly Location of Your GrillType of Gas Portable InstallationInstalling Liquid Propane Tank Handling Liquid Propane GasTemperature-Activated Shut-Off Hand AssemblyDisconnecting Cylinder Liquid Propane Tank Safety TipsRe-install Control Panel Gas Leak ChecksCheck Normal Operation Main Burner Ignition Match Lighting Your Grill Main BurnersSide Burner Electronic Ignition Match Lighting Your Grill Side BurnerRotisserie Burner Electronic Ignition Match Lighting Your Rotisserie BurnerUsing the Rotisserie Operating the Rotisserie Cooking with the RotisserieHelpful Hints Using the Smoke-It-TrayCleaning the Smoke-It-Tray To use the Smoke-It-TrayStoring Liquid Propane Gas Grills Gas Valve Orifice When Using the RotisserieFlare Ups Gauging Amount of Fuel in Liquid Propane TankDay Grill Maintenance Schedule TroubleshootingMaintenance Cleaning the HoodAnnual Maintenance For Rotisserie Burner tube removal Cleaning the Spider/Insect Screens Cleaning the Main BurnerMain Burner Flame Pattern Battery Replacement of Burner Igniter Replacing the Main BurnersGuía del propietario del asador de gas propano licuado Peligros Y Advertencias PeligroAdvertencia Ubicación de la barbacoa Información Sobre LA SeguridadPropuesta 65 DE California EnsamblajeInstalación portátil Tipo de gasManipulación del gas propano licuado Tipo de tanque de propano licuadoControl del exceso de flujo Ensamblaje manualDesconexión del cilindro Cierre activado por temperaturaDetección de fugas de gas ReviseReinstale el panel de control Operación Normal Encendido del quemador principal Encendido electrónico del quemador lateral Encendido con cerillo del quemador lateral de la barbacoaEncendido electrónico del quemador del asador giratorio Encendido con cerillo del quemador del asador giratorioAdvertencias Uso del asador giratorioOperación del asador giratorio Cómo cocinar con el asador giratorioPara usar la bandeja de ahumado Smoke-It-Tray Consejos ÚtilesUso de la bandeja de ahumado Smoke-It-Tray Calentamiento de la bandeja de ahumado Smoke-It-TrayOrificio de la válvula de gas LlamaradasAlmacenaje de las barbacoas de gas propano licuado Al usar el asador giratorioPrograma de mantenimiento de 90 días de la barbacoa Resolución DE ProblemasMantenimiento Limpieza de la campanaMantenimiento Anual Para retirar el tubo del quemador del asador giratorio Limpieza de las mallas contra arañas e insectos Patrón de la llama del quemador principalLimpieza del quemador principal Reemplazo de los quemadores principales Reemplazo de la batería del encendedor de los quemadoresGuide de l’utilisateur du Grill à gaz PL Avertissement Appareils a GAZ Propane Liquide UniquementMontage Choix de l’emplacement de votre grillInformations Relatives a LA Securite Nivelage du solType de gaz Installation portativeInstallation de la bouteille de propane liquide Manipulation du gaz propane liquideContrôle de débit excessif Montage manuelDéconnexion de la bouteille Fermeture activée par la températureRemettez le panneau de commande en place Détection des fuites de gazVérifiez Fermez le couvercle pour faire les grillades Utilisation NormalePréchauffage du grill Post-chauffage du grillAllumage du brûleur principal Susceptible de provoquer une blessure ou la mort Allumage électronique du brûleur latéralAllumage électronique du brûleur de la rôtissoire Allumage du brûleur de votre rôtissoire avec une allumetteAvertissements Utilisation de la rôtissoireCuisson avec la rôtissoire Astuces AvertissmentStockage des Grills à gaz propane liquide Déplacement des grills portatifsEmbrasements Orifice de la valve de gazPlanning de maintenance du grill à 90 jours Guide DE DepannageNettoyage du couvercle Maintenance Annuelle Pour retirer le tube du Brûleur de la rôtissoire Nettoyage des Grilles anti araignées/insectes Aspect de la flamme du brûleur principalNettoyage du brûleur principal Remplacement des brûleurs principaux Remplacement de la pile de l’Allumeur du brûleurPage First Name Last Name North Roselle RD. SCHAUMBURG, IL
Related manuals
Manual 64 pages 17 Kb Manual 64 pages 61.07 Kb Manual 64 pages 54.78 Kb Manual 72 pages 28.86 Kb Manual 72 pages 19.75 Kb

3400 specifications

The Ducane 3400 is a distinguished model in the world of outdoor grills, known for its exceptional performance and robust construction. Designed with the serious grilling enthusiast in mind, this grill combines style, functionality, and user-friendly features that cater to both novice and experienced cooks alike.

One of the standout features of the Ducane 3400 is its powerful heating capability. Equipped with a high-performance main burner system, this grill offers impressive BTU output, ensuring that it heats up quickly and maintains consistent temperatures across the cooking surface. The large cooking area is perfect for grilling large cuts of meat or preparing multiple dishes at once, making it an ideal choice for family gatherings or backyard parties.

Durability is a hallmark of the Ducane 3400. Constructed from high-quality stainless steel, this grill is designed to withstand the elements, resisting rust and corrosion over time. The stainless steel flavorizer bars enhance the grilling experience by distributing heat evenly while adding a smokey flavor to your favorite foods. Additionally, the grill comes with cast iron cooking grates, which provide excellent heat retention and promote beautiful sear marks on your meat.

One of the key technologies incorporated into the Ducane 3400 is its easy-start ignition system. This feature allows for quick and hassle-free lighting, getting you started on your grilling adventure in no time. The intuitive control knobs provide precise temperature management, so you can effortlessly achieve that perfect sear or slow cook your meats to perfection.

The Ducane 3400 is also designed with convenience in mind. It includes side shelves for additional workspace, allowing you to have your tools and ingredients within easy reach while you're grilling. The built-in thermometer provides real-time temperature readings, ensuring your food is cooked to the desired doneness.

In terms of aesthetics, the Ducane 3400 sports a sleek and modern design that can enhance any outdoor kitchen. The elegant finish and thoughtful design make it an attractive centerpiece for your grilling area.

Whether you’re a backyard barbecue aficionado or someone who enjoys weekend cookouts with family, the Ducane 3400 stands out as a reliable and high-performing grill. Its combination of power, durability, and user-friendly features make it an excellent choice for anyone looking to elevate their grilling experience. With the Ducane 3400, you can create delicious meals and lasting memories that will be cherished for years to come.
Top Page Image Contents