Waterford Appliances E65-NG1 Vertical Termination with CO-LINEAR Flex System, Required Parts

Page 14

INSTALLATION

VERTICAL TERMINATION WITH CO-LINEAR FLEX SYSTEM

THE APPLIANCE MUST NOT BE CONNECTED TO A CHIMNEY FLUE SERVING A SEPARATE SOLID FUEL BURNING APPLIANCE.

Masonry chimneys may take various contours which the flexible liner will accommodate. However, keep the flexible liner as straight as possible , avoid unnecessary bending.

The Air Intake pipe must be attached to the inlet air collar of the termination cap.

This appliance is designed to be attached to two 3" (76mm) co-linear aluminium flex running the full length of the chimney. See the Venting Arrangements chart below for minimum and maximum flue lengths. See chart below for minimum distances from roof. Periodically check that the vent is unrestricted.

Required Parts:

Part #

Description

945G

45o Elbow

946-529

Co-linear DV Vertical

 

Termination Cap

948-305

3" Flex - 35 ft.

270-944

U27 Dura-Vent Adapter

946-563

Co-Axial to Co-Linear Adapter Kit

 

which contains the following:

 

Co-linear Flex Adapter (270-585)

 

Outer Pipe (946-257)

 

Inner Pipe Adapter (946-219)

Alternate Approved Caps

980Vertical Termination Cap

991High Wind Cap

923GK 3" Co-linear Adapter with flashing

Venting Arrangements - Vertical Terminations

with Co-linear Flex System for both

Residential & Manufactured Homes/

Mobile Homes

The shaded area in the diagram shows the allowable vertical terminations. If the vent is ENCLOSED in a chase (min. size 9" x 9") maintain a 1-1/4" clearance to combustibles.

Straight Vertical Terminations

14

Waterford E65-1 Emerald Direct Vent Freestanding Gas Stove

Image 14
Contents Emerald Direct Vent Freestanding Gas Stove Models E65-NG1 Natural GasTo the New Owner Unit SpecificationsWaterford Table of Contents Safety Label Copy of Safety Label for E65-NG1 Natural Gas StoveCopy of Safety Label for E65-LP1 Propane Stove Save These Instructions InstallationSpecifications Information for MobileClearances to Combustibles General Safety InformationInstallation Checklist Combustion and Ventilation AIR Locating Your Optional FAN Installation Emerald GAS StoveManufactured Mobile Home Additional Requirements Safety Precautions for the Installer InstallationIntroduction Precautions Ance adapterExterior Vent Terminal Locations Rigid Pipe Venting Components List 4DT-AJBVenting Arrangements Examples Rigid Pipe Venting Horizontal TerminationsHorizontal Venting Vent Restrictor #1 Straight Vertical TerminationsOffset to Vertical Terminations Description Vertical Termination with CO-LINEAR Flex SystemRequired Parts Alternate Approved CapsDV Stove Horizontal Vent KIT Miniumum Horizontal Termination InstallationsMinimum components for a Horizontal Installa- tion Optional ComponentsInstallation Planning Your Dura-Vent Installation DURA-VENT Termination KITMinimum components for a Dura-Vent Vertical Termination Minimum components for a Dura-Vent Horizontal InstallationAlternate Horizontal Termination Caps Dura-Vent Basic Horizontal Kit #Snorkel Terminations DURA-VENT Horizontal InstallationsBelow Grade Snorkel Installation DURA-VENT Vertical Termination # 942 over the vent pipeRound Support RDS Square Support SQS Offset ChartCathedral Ceilings General Prior to installation and connectionSupport Extensions Round Rdse or Square Sqse Converting a Factory Built Metal ChimneyConverting a Masonry Chimney GAS Connection Aeration AdjustmentHigh Elevation With 38,000 BTUValve Description GAS Pipe Pressure TestingConversion KIT from Natural GAS to Propane Propane Conversion Kit 260-922 Contains Reduction KIT to Lower BTU Rating for E65-1 GAS StoveNatural Gas Conversion Kit 260-920 Contains Door Grill Kit Contains LOG InstallationOptional Door Grill Installation Final Check Optional Remote ControlOptional Wall Thermostat Operating Instructions Wiring Diagram E65-NG1 & E65-LP1Lighting Procedure Operating InstructionsCopy of the Lighting Plate instructions Shutdown ProcedureFirst Fire Maintenance Instructions MaintenanceAdjusting Flame Height Automatic Convection FAN OperationGlass Replacement General Vent MaintenanceLOG Replacement FAN MaintenanceRemoving Valve Installing Valve AssemblyTo remove valve from valve assembly, continue To remove fanParts List Main AssemblyBurner & LOG Assembly Waterford E65-1 Emerald Direct Vent Freestanding Gas Stove Waterford E65-1 Emerald Direct Vent Freestanding Gas Stove Page Warranty ConditionsRegister your Waterford online at