Weil-McLain 80 manual Install flue collector

Page 11

• Installation • Start-Up • Maintenance • Parts

6 Install flue collector (continued)

Figure 10 Flue collector components, typical (Model 880 collector configurations shown)

Part No. 550-141-935/0602

11

Image 11

Contents Boiler Manual Contents Lay a foundation, if needed Before installing boilerInstallation must comply with Before selecting boiler locationProvide combustion and ventilation air openings For packaged boiler For block assemblyUsing crane attach free end of cables to eye of crane Set boiler in placePlace a block under pipe to hold section upright Install back refractory blanketAssemble block Prepare back sectionPrepare remaining sections Install intermediate sectionsIf using tankless heater TI sections Prepare boiler and test Perform hydrostatic pressure testInstall cleanout plates Complete block assemblyInstall burner mounting plate on front section Prepare flue collector hood assembly Install flue collectorFlue collector assembly Install collector hold-down boltsInstall flue collector Top flue boilers only Before installing flue collectorAfter installing flue collector, ALL Boilers Rear flue boilers onlyInstall flue collector General water piping information Install pipingConnect water boiler piping Size secondary boiler pump GPM based on following formulas Piping for multiple boilers see FigureGeneral steam piping information Connect steam boiler pipingConnect steam boiler piping Condensate piping to boiler Condensate receiver capacity Multiple Steam Boiler Piping Gravity Condensate Return Install jacket front and rear panels Install jacketBefore installing jacket Install support brackets and railsInstall jacket Install jacket trim Install jacket side panelsInstall jacket top panels Jacket side panel placement Models 380, 480, 580 Jacket side panel placement Models 780, 880 Jacket side panel placement Models 1080, 1180, Jacket top panel placement Size piping no smaller than heater inlet and outlet Pipe tankless heatersTo pipe tankless heaters Install controls Install water boiler controlsInstall controls where shown in and Figure Install steam boiler controlsWater level control locations see Table Select type of venting system Connect breeching and venting systemsGeneral venting information Construct metal breeching Make final adjustments Install burnerWiring and fuel piping Check boiler for gas-tight seal Freeze protection when usedDimensions and ratings Dimensions and ratings Parts Parts Eye Irrigate immediately Breathing Fresh air Handling ceramic fiber and fiberglass materialsPropane boilers propane gas odorant All Residential & Commercial Cast Iron Boilers

Related manuals

Manual 44 pages 43.26 Kb