Weil-McLain 80 manual Install jacket

Page 21

• Installation • Start-Up • Maintenance • Parts

9 Install jacket (continued)

Figure 20 Installing jacket support brackets and rails and jacket front and rear panels

Part No. 550-141-935/0602

21

Image 21

Contents Boiler Manual Contents Installation must comply with Before installing boilerBefore selecting boiler location Lay a foundation, if neededProvide combustion and ventilation air openings Using crane attach free end of cables to eye of crane For block assemblySet boiler in place For packaged boilerAssemble block Install back refractory blanketPrepare back section Place a block under pipe to hold section uprightInstall intermediate sections If using tankless heater TI sectionsPrepare remaining sections Prepare boiler and test Perform hydrostatic pressure testComplete block assembly Install burner mounting plate on front sectionInstall cleanout plates Flue collector assembly Install flue collectorInstall collector hold-down bolts Prepare flue collector hood assemblyInstall flue collector After installing flue collector, ALL Boilers Before installing flue collectorRear flue boilers only Top flue boilers onlyInstall flue collector Install piping Connect water boiler pipingGeneral water piping information Size secondary boiler pump GPM based on following formulas Piping for multiple boilers see FigureGeneral steam piping information Connect steam boiler pipingConnect steam boiler piping Condensate piping to boiler Condensate receiver capacity Multiple Steam Boiler Piping Gravity Condensate Return Before installing jacket Install jacketInstall support brackets and rails Install jacket front and rear panelsInstall jacket Install jacket side panels Install jacket top panelsInstall jacket trim Jacket side panel placement Models 380, 480, 580 Jacket side panel placement Models 780, 880 Jacket side panel placement Models 1080, 1180, Jacket top panel placement Pipe tankless heaters To pipe tankless heatersSize piping no smaller than heater inlet and outlet Install controls Install water boiler controlsInstall controls where shown in and Figure Install steam boiler controlsWater level control locations see Table Connect breeching and venting systems General venting information Construct metal breechingSelect type of venting system Install burner Wiring and fuel pipingMake final adjustments Check boiler for gas-tight seal Freeze protection when usedDimensions and ratings Dimensions and ratings Parts Parts Eye Irrigate immediately Breathing Fresh air Handling ceramic fiber and fiberglass materialsPropane boilers propane gas odorant All Residential & Commercial Cast Iron Boilers

Related manuals

Manual 44 pages 43.26 Kb