Cornelius R-404A REFRIGERANT service manual Tubing Assembly Water Solenoid to Blender

Page 85

Item				1
Item	Part No.	Name		2
No.				2
No.
	2779	Tube Ass’y, Water Solenoid to	5	3
	2779	Tube Ass’y, Water Solenoid to		2
		Blender		2
1	311742000	Connector, Barb
2	176001000	Ferrule, .375 O.D. Tube
3	174103000	Tube, .250 I.D. By 11-In. Long		4
4	309854000	Clamp, .400 O.D. Tube		4
4	309854000	Clamp, .400 O.D. Tube
5	77900500	Turnaround, Barb		3
				3
6	77040100	Fitting, Elbow, Swivel, 7/16-20		2
				6
	FIGURE 29. TUBING ASSEMBLY (WATER SOLENOID TO BLENDER)
Item				5
Item				2
No.	Part No.	Name		1
				1
	326098000	Tube Ass’y, Regulator to Blender	2
			2
1	174103000	Tube, .250 I.D. 48-In. Long	3
2	176001000	Ferrule, .375 O.D. Tube	4
3	176017000	Nut, Swivel, 7/16-20
4	770104000	Nipple, .250 I.D. Tube
5	311741000	Connector, Barb
		FIGURE 30. TUBING ASSEMBLY (REGULATOR TO BLENDER)
Item
No.	Part No.	Name
	311764001	Single Check Valve Ass’y
1	317965000	Retainer		6
				6
2	312196000	Spring		5
				5
3	312419000	Ball		4
4	312415000	Washer, .300 I.D.		4
4	312415000	Washer, .300 I.D.		3
5	312418000	Quad Ring, .329 I.D.		3
5	312418000	Quad Ring, .329 I.D.
6	317963000	Receptacle	2
6	317963000	Receptacle
			1

FIGURE 31. DOUBLE CHECK VALVE ASSEMBLY

312028000

78

Image 85

Contents To the Installer Table of Contents Table of Contents cont’d VIS Read Actual Viscosity Readout of Product Programming Main Menu Selections Onto Message DisplayWater Strainer Screen and Double Liquid Check Valve Preparing Unit for SHIPPING, STORING, or RelocatingDaily Cleaning of Unit Sanitizing Syrup Systems Product Carbonation AdjustmentTroubleshooting Control Panel Switches and Fault ‘‘ERROR 1’’ or ‘‘ERROR 2’’ Fault Message Goes on DuringFreeze Cylinder Automatic Defrost Cycle does not Defrost Cycle does not Cancel After Pressing ‘‘CANCELList of Figures Table of Contents cont’d Unit Description General DescriptionService Tools AccessoriesTheory of Operation Generic Flavor TabsManual Defrost System Defrost SystemsAutomatic Defrost System ‘‘WAKE UP’’ Wake UP Time ‘‘SLEEP’’ Sleep TimeFlow Diagram This page Left Blank Intentionally Identification of LOOSE-SHIPPED Parts Unpacking and InspectionSelecting Location Electrical Power RequirementsHZ Unit Installing Leveling Legs Installing UnitInstalling Drip Tray Supports Item 7 and Item Installing Drip Tray Drain Hose KIT ItemConnecting CO2 Source Line to Unit CO2 Inlet Line Installing Primary CO2 Regulator Assembly on CO2 CylinderConnecting Electrical Power Circuit to the Unit Connecting City Plain Water Source Line to UnitElectrical BOX Adjusting Primary CO2 Regulator Turning on Electrical Power to UnitAdjusting Product Blender Tanks Secondary CO2 Adjusting Carbonator Secondary CO2 RegulatorControl Panel ASS’Y Hidden Security Switch Message DisplayChecking Unit for SYRUP, CO2, or Plain Water Leaks Filling Freeze Cylinders with ProductPlacing Unit in Operating Location Adjusting Beater Motor Current Either SideProgramming Main Menu Selection Onto Message Display Setting Clock Time of DAYMenu Selections Programming ‘‘DEFROST’’ Automatic Settings Into UnitMain Menu Selections DIP Switch Functions Switch FunctionProgramming ‘‘SLEEP’’ Sleep Time Into Unit Programming Point of Sale Message Display Programming ‘‘WAKE UP’’ Wake UP Time Into UnitAdjusting VIS SET Product Viscosity of Dispensed Product Master and Relay Circuit Board ‘‘VOLTAGE’’ Displayed Voltage Readout 312028000 Syrup Minutes Side Totals Menu Commands DescriptionBrix Gallons = a X Syrup MinutesProgramming Proper Refrigerant Type Into Unit Electronics Displayed Error ConditionsDisplayed Error Conditions Control Panel ASS’Y Switches Control Panel ASS’Y Switches and Displayed Messages‘‘SECURITY SWITCH.’’ Control Panel Assembly Display MessagesFreeze Cylinders Manual or Automatic Defrost Systems Faceplate Relief Valves ‘‘SLEEP’’ Sleep Time OperationProduct Sample Valves Product Shutoff ValvesDispensing Valves Syrup Flow RegulatorsDispensed Product Conditions ‘‘OVERRUN’’, AS Applied to Frozen Carbonated BeveragesOperating Unit Operating CharacteristicsReplenishing Syrup Supply Cleaning Condenser Coil Cleaning and SanitizingProduct Flavor Change Checking CO2 SupplyAdjustments Adjusting ‘‘VIS SET’’ Product Viscosity of Dispensed Product Cleaning CO2 GAS Check Valves Periodic Inspection Preparing Unit for SHIPPING, STORING, or RelocatingTOP Panel Back PanelFront Access Panel Opening and Closing Front Access DoorOpening Front Access Door Closing Front Access DoorOperating Controls Unit Internal Components SELF-CLOSING Dispensing Valve 312028000 Adjusting Carbonated Water Flow Rate Adjusting Plain Water Pressure RegulatorFreeze Cylinder Cutaway View Servicing Beater Motor Drive SHAFT/SEAL Assembly Beaters and Scraper Blades Installation Adjusting CO2 Regulators Adjusting Brix WATER-TO-SYRUP ‘‘RATIO’’ of Dispensed Product Daily Cleaning of Unit Product Carbonation AdjustmentSanitizing Syrup Systems To disconnect soft drink tank from Unit syrup system 312028000 Servicing Carbonator Water Pump Water Strainer Screen Yearly or After Water System DisruptionServicing Carbonator Water Pump Double Liquid Check Valve Liquid Check Valve AssemblyReplenishing Syrup Supply Replenishing CO2 Supply Service and Maintenance SectionSyrup Flavor Change Water Strainer Screen and Double Liquid Check Valve Replacing Freeze Cylinder Beater Drive Motor ServicedMents in Small Increments Adjusting Carbonator Tank Liquid LevelCarbonator Liquid Level Control Switch Adjustment Refrigeration Flow Diagram Wiring Diagram This page Left Blank Intentionally Troubleshooting Control Panel Switches and Fault Messages Poorly Illuminated Display ONE or More Fault Control Panel SwitchesALL Fault Messages not a Cannot be Deactivated‘‘CO2 OUT’’ Fault Message ALL Fault Message not‘‘H2O OUT’’ Fault Message Fault Message Goes onTroubleshooting Product Blender Tanks and Carbonator Troubleshooting Dispensed Product Consistency Varies Frozen ProductExcessively FREEZE-UPUnit Part Numbers Illustrated Parts BreakdownOvercounter FCB POST-MIX Dispenser FCB POST-MIX Dispenser FCB POST-MIX Dispenser cont’d Name Secondary CO2 Regulator Components Secondary CO2 Regulator ASS’Y CO2 Regulator Assembly Blender and Tubing Components Tubing Assembly Carb Water Tubing Assembly Water Solenoid to Blender Solenoid Valve Assembly Blender Components Control BOX and Display Panel Components Faceplate Assembly Dispensing Valve Assembly Carbonator Components Carbonator Tank and Linkage Assembly Pump and Motor ASS’Y Beater Motor Drive SHAFT/SEAL ASS’Y Warranty This page Left Blank Intentionally One Cornelius Place Anoka, Minnesota 612 800