Multiquip DCA-45US1 operation manual Battery, Transporting

Page 12

DCA-45USI — RULES FOR SAFE OPERATION

NEVER run engine without air filter.Severe engine damage may occur.

ALWAYS service air cleaner frequently to prevent engine malfunction.

ALWAYS disconnect the negative battery terminal before performing service on the generator.

ALWAYS be sure the operator is familiar with proper safety precautions when operating the generator set.

ALWAYS store equipment properly when not in use.

DO NOT leave the generator running in the manual mode unattended.

DO NOT allow unauthorized people to operate this equipment.

ALWAYS read, understand, and follow procedures in Operator’s Manual before attempting to operate equipment.

Refer to the Isuzu Engine Owner's Manual for engine technical questions or information.

Battery

The battery contains acids that can cause injury to the eyes and skin.To avoid eye irritation, always wear safety glasses. Use well insulated gloves when picking up the battery. Use the following guidelines when handling the battery:

1.DO NOT drop the battery. There is the possibility of risk that the battery may explode.

2.DO NOT expose the battery to open flames, sparks, cigarettes etc. The battery contains combustible gases and liquids. If these gases and liquids come in contact with a flame or spark, an explosion could occur.

DANGER:

Pay close attention to ventilation when operating the generator inside tunnels and caves. The

engine exhaust contains noxious elements. Engine exhaust must be routed to a ventilated area.

Generator Grounding

To guard against electrical shock and possible damage to the equipment, it is important to provide a good EARTH ground.

Article 250 (Grounding) of the National Electrical Code (NEC) provides guide lines for proper grounding and specifies that the cable ground shall be connected to the grounding system of the building as close to the point of cable entry as practical.

ALWAYS be sure to use the ground terminal (green wire) when connecting a load to the UVWO output terminals.

3.ALWAYS keep the battery charged. If the battery is not charged a buildup of combustible gas will occur.

4.ALWAYS keep battery charging and cables in good working condition. Repair or replace all worn cables.

5.ALWAYS recharge the battery in an vented air environment, to avoid risk of a dangerous concentration of combustible gases.

6.In case the battery liquid (dilute sulfuric acid) comes in contact with clothing or skin, rinse skin or clothing immediately with plenty of water.

7.In case the battery liquid (dilute sulfuric acid) comes in contact with your eyes, rinse eyes immediately with plenty of water, then contact the nearest doctor or hospital, and seek medical attention.

Transporting

ALWAYS shutdown engine before transporting.

Tighten both fuel tank caps securely.

If generator is mounted on a trailer, make sure trailer complies with all local and state safety transportation laws. See next page “Towing Safety Precautions” for basic towing techniques.

PAGE 12 — DCA-45USI — OPERATION AND PARTS MANUAL (STD) — REV. #2 (04/22/05)

Image 12
Contents DCA-45USI 2 DCA-45USI Operation and Parts Manual STD REV. #2 04/22/05 Heres HOW to GET Help Wilmington Ave Carson, CATable of Contents Parts Ordering Procedures When ordering parts Please supply the following informationDCA-45USI Specifications DCA-45USI Dimensions Side and Front DimensionsDCA-45USI Safety Message Alert Symbols For Your Safety and the Safety of Others DCA-45USI Safety Message Alert Symbols General Safety DCA-45USI Rules for Safe OperationDCA-45USI Rules for Safe Operation RadiatorBattery TransportingTowing Safety Precautions EmergenciesDCA-45USI Installation Typical Generator Grounding ApplicationOutdoor Installation MountingDCA-45USI -TOWING Safety Precautions DCA-45USI -TRAILER Specifications Explanation of ChartDCA-45USI Generator Decals DCA-45USI Generator Decals DCA-45USI General Information Three auxilliary circuit breakers, @50 ampsDCA-45USI Major Components DCA-45USI Generator Control Panel Generator Control PanelWater Temperature Lamp Indicates that the water Fuel FilterWater Level Alarm Lamp This lamp turnsFuel Leak Detected Alarm This indicates that liquid DCA-45USI Engine Operating PanelDCA-45USI Output Terminal Panel Familiarization Output Terminal PanelOutput Terminal Familiarization DCA-45USI Output Terminal Panel Familiarization 120VAC Gfci ReceptaclesConnecting Loads Over Current RelayBlower Fan Single Phase Load Three Phase LoadDCA-45USI Load Application If 3Ø load kVA is not given onVoltage Selector Switch Voltage Selector Switch Locking ButtonGenerator Amperage Generator OutputVoltagesHow to Read the OutputTerminal Gauges DCA-45USI Gauge ReadingReading Amperage Reading VoltageDCA-45USI Output Terminal Panel Connections Uvwo Terminal Output Voltages3Ø 240/139 Output Terminal Lug Voltages 3Ø 208V/1Ø120V Output Terminal Lug Voltages3Ø 480/277 Output Terminal Lug Voltages 1Ø 240V/120V Output Terminal Lug VoltagesDCA-45USI PRE-SETUP Circuit BreakersLubrication Oil Fuel CheckRefueling Procedure When refuelingInhaling fumes ALWAYS! place trailer on firm level ground before refuelingCleaning the Radiator Air Cleaner Fan Belt TensionMust be less than 50% Operation Freezing WeatherBattery Cable Installation WiringAlternator Piping and Hose ConnectionDCA-45USI Generator START-UP Procedure Before StartingDCA-45USI Generator START-UP Procedure 38 DCA-45USI Operation and Parts Manual STD REV. #2 04/22/05 Normal Shut-down Procedure Emergency Shut-down ProcedureAutomatic Shut-down System DCA-45USI Maintenance Air Removal Check Oil LevelReplacing Oil Filter Replacing Fuel FilterDCA-45USI -TRAILER Brakes Maintenance Brake AdjustmentBrakes Hydraulic Surge BrakesDCA-45USI -TRAILER Maintenance Tires/Wheels/Lug NutsTireWear/Inflation SuspensionLug Nut Torque Requirements Start all wheel lug nuts by handDCA-45USI -TRAILERWIRING Diagram Trailer/Towing Vehicle Wiring DiagramDCA-45USI Enginewiring Diagram DCA-45USI Enginewiring Diagram DCA-45USI Generatorwiring Diagram Generator Wiring DiagramDCA-45USI -TROUBLESHOOTING Generator Explanation of Code in Remarks Column Items Found In the Items Number ColumnDCA-45USI Suggested Spare Parts Qty DescriptionDCA-45USI Generator Assy B3110100202 80510700030010310035 0042510000DCA-45USI Control BOX Assy M1214000102 0601808825KAF361101039 002100508056 DCA-45USI Operation and Parts Manual STD REV. #2 04/22/05 DCA-45USI Control BOX Assy DCA-45USI Engine and Radiator Assy M1924200014 897049-70810605000048 0030010000Engine & Radiator Assy 0603300285 06055113950603306395 0602021070DCA-45USI Outputterminal Assy DCA-45USI Outputterminal Assy DCA-45USI Battery Assy 0602220187 M9310500014M9103000304 0602220920DCA-45USI Muffler Assy M1331100102 0017112030M1334000003 0602320101DCA-45USI Fueltank Assy M1364000102 06055050700605501072 0605516090DCA-45USI Enclosure Assy DCA-45USI Enclosure Assy 72 DCA-45USI Operation and Parts Manual STD REV. #2 04/22/05 26A 0040016000 26B 004121600027A 0040016000 27B 004121600074 DCA-45USI Operation and Parts Manual STD REV. #2 04/22/05 49A M1494400404 M145400010350A M1494400104 M1454000503DCA-45USI Rubber Seals Assy 0229200950 02289013850228900900 0229400900DCA-45USI Nameplate and Decals Assy M1511400002 M1511400102M1550000204 M15000020Effective October 1, 2002 Terms and Conditions of Sale Parts DCA-45USI Operation and Parts Manual STD REV. #2 04/22/05 Your Local Dealer is