Manuals / Alto-Shaam / Kitchen Appliance / Refrigerator

Alto-Shaam QC-3/QC-20/QC-40/QC-50/QC-50 Remote/QC-100/Qc-100 Remote MODEL QC-50 WIRING 1PH 3PH

Models: QC-3/QC-20/QC-40/QC-50/QC-50 Remote/QC-100/Qc-100 Remote

1 60

Download 60 pages 22.76 Kb

Page 45

Image 45

S ETRITVLICE E

MODEL: QC-50 WIRING

1PH

3PH

Part numbers and drawings are subject to change without notice.

QUICKCHILLER • INSTALLATION/OPERATION/SERVICE MANUAL • 4 3 .

Page 45

Image 45

Alto-Shaam QC-3/QC-20/QC-40/QC-50/QC-50 Remote/QC-100/Qc-100 Remote manual MODEL QC-50 WIRING 1PH 3PH, S Etritvlice E

Contents

MAINTENANCE INSTALLATIONOPERATION PHONE 262.251.3800 800.558.8744 USA/ CANADACare and Cleaning InstallationService Wire DiagramsD E L I V E R Y U N P A C K I N GSee Transportation Damage and Claims section located in this manual D A N G E R SAFETY PROCEDURES AND PRECAUTIONSW A R N I N G C A U T I O NSITE INSTALLATION INSTALLATIONIMPROPER INSTALLATION ALTERATION, ADJUSTMENT SERVICE, OR MAINTENANCE COULD RESULT IN SEVERE INJURY, DEATHWATER DRAINAGE INSTALLATION REQUIREMENTSDOOR SEAL DRAINAGETrolley Guide Installation TROLLEY GUIDE INSTALLATIONSITE INSTALLATION I N S T A L L A T I O NI N S TTAILTLLAET I O N SITEUB TITLEINSTALLATIONQC-3 WEIGHTQC-20 I N S TTAILTLLAET I ONSITEUB TITLEINSTALLATION WEIGHTSITEUB TITLEINSTALLATION QC-40WEIGHT volume maximum 90 quarts 85 litersQC-50 Remote QC-50SITEUB TITLEINSTALLATION WEIGHTQC-100 Remote QC-100SITEUB TITLEINSTALLATION WEIGHTMODEL OPTIONSSUB TITLEAND ACCESSORIESI N S TTAILTLLAET I ON QC-3DANGER ELECTRICAL SPECIFICATIONSELECTRICALSUB TITLE D A N G E ROPERATING INTRODUCTION O P ETRITALTEI O N1. TRADITIONAL COOK-SERVE KITCHENS 2. MODIFIED COOK-CHILL OPERATIONSCHILL PROCESSING CYCLES TEMPERATURE ABOVE 140F 60C AND MUST BE TIGHTLY COVEREDQUICKCHILLER OPERATION MODES INITIAL QUICKCHILLER OPERATIONADDITIONAL INFORMATION POWER OUTAGEFAN OPERATION DOORCONTROL PANEL IDENTIFICATION O P ETRITALTEI O Na c e f g MANUAL OPERATION BASICSUB TITLEOPERATION2d 2c C A U T I O NADVANCEDSUB TITLE OPERATION WHEN IN THE HOLD TEMP MODE AFTER A CHILL MODEHOLD TEMP NEVER STACK PANS DIRECTLY ON TOP OF EACH OTHERWHEN IN THE HOLD TEMP MODE AFTER CHILLING BY PROBE FACTORY DEFAULT SET POINTSQUICK FREEZE, HARD CHILL, SOFT CHILL Chilling by TimePROGRAMMING PRESETS PRESET PROGRAM OPERATIONPRESET SELECTIONS O P E R A T I O NCHANGING USER SETTINGS USER SETTINGS7. HOLD DEFAULT PROGRAMMING USER SETTINGS 1. START MANUAL DEFROSTProbe Cleaning Procedures USER INFORMATION Time & Temperature GuidelinesFOOD PROBE USE Automatic DefrostPRODUCT COVERING FOODSUB TITLEHANDLING GUIDELINESPORTIONING & PACKAGING O P ETRITALTEI O NQ U I C K C H I L L E R P A N C A P A C I T Y C H A R T QUICKCHILLER PAN CAPACITYPRODUCT CAPACITY PER PAN I N D I V I D U A L P A N C A P A C I T I E SP O R T I O N S I Z E S a n d P A N C A P A C I T I E S THE FOLLOWING CHART OF PORTION SIZES AND SERVING CAPACITYPER PAN IS PROVIDED AS A GENERAL REFERENCE ONLY PAN SIZE ›CLEANING AND PREVENTIVE MAINTENANCE CARE ANDTI T CLEANINGECLEANING AGENTS CLEANING MATERIALSEXTERIOR CLEANING INTERIOR CLEANINGDISCONNECT UNIT FROM POWER SOURCE BEFORE CLEANING OR SERVICING PROBE CLEANING PROCEDURESUsing Default Function Values CONTROL ERROR DISPLAYSPower Failure T R O U B LTEITSLHEO O T I N GSW-34152 MODEL QC-3 CONTROLBA-34021 BA-34009MODEL QC-3 COIL S ETRITVLICE E5009220 CB-33389BA-33554 control MODEL QC-20 CONTROL5002433 S ETRITVLICE E5009220 VA-33932 MODEL QC-20 COILEL-34046 S ETRITVLICE ES ETRITVLICE E MODEL QC-20 CONDENSERcondensate pan not shownDefrost Heater - CB-34199 MODEL QC-40Evaporator Coil Coil Sensor - SN-335415006727 MODEL QC-40 CONTROLS ETRITVLICE E BA-33554S ETRITVLICE E MODEL QC-50, QC-100 CONTROLBA-33554 BA-34010VA-34128 qc-50 RWEV48 qc-100 MODEL QC-100 COILCR-33387 EL-34268MODEL QC-50, QC-100 FAN MODEL QC-50, QC-100 BREAKERSW-34153 QC-50 SW-34154 QC-100 - 208-240V, 1PH SW-34153 QC-100 - 208-240V, 3PH SW-34152 QC-100 - 380-415V, 3PHMODEL QC-50 Remote Terminal SwitchesCoil Sensor Defrost HeaterMODEL QC-50, QC-100 REMOTE Remote condensor connection Circuit Breaker Connect wires to condensing unit solenoid hereLow Side Connection High Side Connection S ETRITVLICE ES ETRITVLICE E MODEL QC-3 WIRING MODEL QC-20 WIRINGS ETRITVLICE E MODEL QC-40 WIRINGS ETRITVLICE E MODEL QC-50 WIRING 1PH 3PHS ETRITVLICE E MODEL QC-100 WIRINGPage Page Page Page Page Page Page Page Page Page Page Page Page LIMITED WARRANTY TRANSPORTATION DAMAGE and CLAIMSVoltage Purchased From