Manuals / Alto-Shaam / Kitchen Appliance / Refrigerator

Alto-Shaam QC-3/QC-20/QC-40/QC-50/QC-50 Remote/QC-100/Qc-100 Remote manual MODEL QC-100 WIRING

Models: QC-3/QC-20/QC-40/QC-50/QC-50 Remote/QC-100/Qc-100 Remote

1 60

Download 60 pages 22.76 Kb

Page 46

Image 46

S ETRITVLICE E

MODEL: QC-100 WIRING

1PH

3PH

Part numbers and drawings are subject to change without notice.

QUICKCHILLER • INSTALLATION/OPERATION/SERVICE MANUAL • 4 4 .

Page 46

Image 46

Alto-Shaam QC-3/QC-20/QC-40/QC-50/QC-50 Remote/QC-100/Qc-100 Remote manual MODEL QC-100 WIRING, S Etritvlice E

Contents

OPERATION INSTALLATIONMAINTENANCE PHONE 262.251.3800 800.558.8744 USA/ CANADAService InstallationCare and Cleaning Wire DiagramsU N P A C K I N G D E L I V E R YSee Transportation Damage and Claims section located in this manual W A R N I N G SAFETY PROCEDURES AND PRECAUTIONSD A N G E R C A U T I O NIMPROPER INSTALLATION ALTERATION, ADJUSTMENT INSTALLATIONSITE INSTALLATION SERVICE, OR MAINTENANCE COULD RESULT IN SEVERE INJURY, DEATHDOOR SEAL INSTALLATION REQUIREMENTSWATER DRAINAGE DRAINAGESITE INSTALLATION TROLLEY GUIDE INSTALLATIONTrolley Guide Installation I N S T A L L A T I O NQC-3 SITEUB TITLEINSTALLATIONI N S TTAILTLLAET I O N WEIGHTSITEUB TITLEINSTALLATION I N S TTAILTLLAET I ONQC-20 WEIGHTWEIGHT QC-40SITEUB TITLEINSTALLATION volume maximum 90 quarts 85 litersSITEUB TITLEINSTALLATION QC-50QC-50 Remote WEIGHTSITEUB TITLEINSTALLATION QC-100QC-100 Remote WEIGHTI N S TTAILTLLAET I ON OPTIONSSUB TITLEAND ACCESSORIESMODEL QC-3ELECTRICALSUB TITLE ELECTRICAL SPECIFICATIONSDANGER D A N G E R1. TRADITIONAL COOK-SERVE KITCHENS O P ETRITALTEI O NOPERATING INTRODUCTION 2. MODIFIED COOK-CHILL OPERATIONSQUICKCHILLER OPERATION MODES TEMPERATURE ABOVE 140F 60C AND MUST BE TIGHTLY COVEREDCHILL PROCESSING CYCLES INITIAL QUICKCHILLER OPERATIONFAN OPERATION POWER OUTAGEADDITIONAL INFORMATION DOORO P ETRITALTEI O N CONTROL PANEL IDENTIFICATIONa c e f g 2d 2c BASICSUB TITLEOPERATIONMANUAL OPERATION C A U T I O NHOLD TEMP WHEN IN THE HOLD TEMP MODE AFTER A CHILL MODEADVANCEDSUB TITLE OPERATION NEVER STACK PANS DIRECTLY ON TOP OF EACH OTHERQUICK FREEZE, HARD CHILL, SOFT CHILL FACTORY DEFAULT SET POINTSWHEN IN THE HOLD TEMP MODE AFTER CHILLING BY PROBE Chilling by TimePRESET SELECTIONS PRESET PROGRAM OPERATIONPROGRAMMING PRESETS O P E R A T I O N7. HOLD DEFAULT USER SETTINGSCHANGING USER SETTINGS PROGRAMMING USER SETTINGS 1. START MANUAL DEFROSTFOOD PROBE USE USER INFORMATION Time & Temperature GuidelinesProbe Cleaning Procedures Automatic DefrostPORTIONING & PACKAGING FOODSUB TITLEHANDLING GUIDELINESPRODUCT COVERING O P ETRITALTEI O NPRODUCT CAPACITY PER PAN QUICKCHILLER PAN CAPACITYQ U I C K C H I L L E R P A N C A P A C I T Y C H A R T I N D I V I D U A L P A N C A P A C I T I E SPER PAN IS PROVIDED AS A GENERAL REFERENCE ONLY THE FOLLOWING CHART OF PORTION SIZES AND SERVING CAPACITYP O R T I O N S I Z E S a n d P A N C A P A C I T I E S PAN SIZE ›CLEANING AGENTS CARE ANDTI T CLEANINGECLEANING AND PREVENTIVE MAINTENANCE CLEANING MATERIALSDISCONNECT UNIT FROM POWER SOURCE BEFORE CLEANING OR SERVICING INTERIOR CLEANINGEXTERIOR CLEANING PROBE CLEANING PROCEDURESPower Failure CONTROL ERROR DISPLAYSUsing Default Function Values T R O U B LTEITSLHEO O T I N GBA-34021 MODEL QC-3 CONTROLSW-34152 BA-340095009220 S ETRITVLICE EMODEL QC-3 COIL CB-333895002433 MODEL QC-20 CONTROLBA-33554 control S ETRITVLICE EEL-34046 MODEL QC-20 COIL5009220 VA-33932 S ETRITVLICE Econdensate pan MODEL QC-20 CONDENSERS ETRITVLICE E not shownEvaporator Coil MODEL QC-40Defrost Heater - CB-34199 Coil Sensor - SN-33541S ETRITVLICE E MODEL QC-40 CONTROL5006727 BA-33554BA-33554 MODEL QC-50, QC-100 CONTROLS ETRITVLICE E BA-34010CR-33387 MODEL QC-100 COILVA-34128 qc-50 RWEV48 qc-100 EL-34268SW-34153 QC-50 SW-34154 QC-100 - 208-240V, 1PH MODEL QC-50, QC-100 BREAKERMODEL QC-50, QC-100 FAN SW-34153 QC-100 - 208-240V, 3PH SW-34152 QC-100 - 380-415V, 3PHCoil Sensor Terminal SwitchesMODEL QC-50 Remote Defrost HeaterLow Side Connection High Side Connection Circuit Breaker Connect wires to condensing unit solenoid hereMODEL QC-50, QC-100 REMOTE Remote condensor connection S ETRITVLICE EMODEL QC-3 WIRING MODEL QC-20 WIRING S ETRITVLICE EMODEL QC-40 WIRING S ETRITVLICE EMODEL QC-50 WIRING 1PH 3PH S ETRITVLICE EMODEL QC-100 WIRING S ETRITVLICE EPage Page Page Page Page Page Page Page Page Page Page Page Page TRANSPORTATION DAMAGE and CLAIMS LIMITED WARRANTYVoltage Purchased From