Manuals / GE / Kitchen Appliance / Refrigerator

GE SSS25, GSS22, GSS20, GSS25, ESS25, ESS22, HSS25, HSS22 manual Fresh Food Air Damper, Cable Connector

Models: SSS25 HSS22 HSS25 ESS22 ESS25 GSS25 GSS20 GSS22

1 70

Download 70 pages 3.51 Kb

Page 31

Image 31

Cable

Connector

GEA00900

4.Remove 2 Phillips screws from the solenoid connection.

5.Disconnect the water tube and remove the solenoid.

Fresh Food Air Damper

The fresh food air damper is located in the upper left corner of the fresh food compartment. The damper opens to allow cold air to circulate from the freezer to the fresh food compartment.

1.Remove 2 damper cover screws.

2.Remove the damper cover.

3.Using a flat-head screwdriver, remove the damper assembly from the mullion divider until the wire connector is exposed.

4.Disconnect the motor wire connectors.

5.Damper will be replaced as an assembly.

– 29 –

Page 31

Image 31

GE SSS25, GSS22, GSS20, GSS25, ESS25, ESS22, HSS25, HSS22 manual Fresh Food Air Damper, Cable Connector

Contents

General Electric Side-by-Side Knob Control/Metal Liner Refrigerator PUB # 31-9071 02/01TECHNICAL SERVICE GUIDE GE Consumer Home Services TrainingGE Consumer Home Services Training IMPORTANT SAFETY NOTICERECONNECT ALL GROUNDING DEVICES Mechanical Disassembly Diagnostics Table of ContentsIntroduction Installation Specifications Nomenclature Warranty Information Operating Characteristics General Locator ViewsIntroduction FRANÇAIS ESPANOL Installation197D3266P001 31-5087 9-00 JR Specifications G S S 2 5 I F M A F W W Nomenclatureany labor or in-home service costs Warranty Informationcompressor, condenser, evaporator, and all connecting this limited lifetime warranty, you will be responsible forTable of Contents Operating CharacteristicsPre-Chill Operation Adaptive Defrost Abnormal Operating Characteristics Incorrect OperationCooling Operation Adaptive Defrost Adaptive DefrostLiner Protection Mode Defrost Heater Operation Adaptive DefrostDwell Period Adaptive Defrost Post Dwell Adaptive DefrostHinge System and Door Closure Dispenser LockFilters “Jelly Roll” Condenser Airflow Cabinet InteriorPROCESSING Main Control BoardINPUTS OUTPUTSLocation General Locator ViewsFreezer Light Switch Fresh Food Light Switch Damper Fresh Food Temperatureunder cover Main Control Board Condenser Fan Jelly Roll Condenser CompressorWater Solenoids CapacitorOvertemperature Thermostat and Evaporator Thermistor Mechanical DisassemblyFresh Food Door Adjustment Control Panel Fresh Food Light Freezer Door Light Switch Water Filter Cartridge ShelvesIce Cube Solenoid Evaporator Condenser Fan Dispenser Heater Door Dispenser Target Switch Ice Crusher Ice Dispenser Drive MotorMain Control Board Roller Assembly Water Solenoid Fresh Food Thermistor Door Dispenser Control PanelDoor Removal Door GasketDoor Handles Doors and Door HingesControl Panel Fresh Food Door AdjustmentMounting Nuts Freezer Door Light SwitchFresh Food Light Water Filter CartridgeDrawers and Bins ShelvesWater Filter Cartridge Icemaker Freezer LightDoor Shelf Extenders 2 Screws Cable ConnectorIce Dispenser Drive Evaporator FanFreezer Thermistor 2 Connectors 2 ScrewsHeater Wiring Harness Defrost Heater and Freezer ThermistorFresh Food Thermistor Overtemperature Thermostat and Evaporator ThermistorDoor Dispenser Target Switch Door Dispenser Control PanelIce Dispenser Drive Motor Ice CrusherIce Cube Solenoid Wiring ConnectorsSolenoid Ground Wire Motor EvaporatorScrew Condenser FanDispenser Heater ScrewsMain Processor Card Roller AssemblyAdjusting Screw Guide Pin Roller Water SolenoidCable Connector Fresh Food Air DamperPage Page Fresh Food Warm - Freezer Warm Diagnostic Chart DiagnosticsEfficient Use of Diagnostics Efficient Use of Diagnostics Failure Causes TableAbove Failure CausesFreezer Compartment Fresh Food CompartmentINPUTS Sample only, check schematic shipped with productMain Control Board Low-Voltage Side PROCESSING UNITOUTPUTS Main Control Board 120 VAC SidePROCESSING UNITComponent ConnectorWire Color Main Control Board Locator Table Low-Voltage SideSee schematic ConnectorWire Color See schematicWhen activated Reset electronics by unplugging refrigerator for 15 seconds Fresh Food Warm - Freezer WarmBasic refrigerator checks Check control settings and temperatures Freezer Warm - Fresh Food Normalrefrigerator for 15 seconds refrigerator for 15 seconds Fresh Food Warm - Freezer NormalCheck control settings and temperatures Basic refrigerator checksReset electronics by unplugging refrigerator for 15 seconds Fresh Food Too Cold - Freezer NormalGo to Damper Not Operating Flowchart Refrigerator Dead, No Sound, No Cooling Evaporator Fan Not Running Condenser Fan Not Running Damper Door Not Operating Compressor Not Running Heavy Frost on Evaporator Resistance in Kilo Table 2. Thermistor ValuesTemperature TemperatureGEA00916 Component and Connector Locator ViewsEvaporator Fan Light Evaporator ThermistorDefrost Thermostat Evaporator Defrost Heater Freezer ThermistorGEA00913 Fresh Food Light SwitchDamper Fresh Food Thermistor Fresh Food Lightsunder cover Main Control Board Condenser Fan Jelly Roll Condenser CompressorWater Solenoids CapacitorUNIT Main Control Board 120 VAC SideOUTPUTS PROCESSINGMAIN CONTROLBOARD SchematicsSEE INDIVIDUAL DIAGRAM DIAGRAMPage REV H and higher Page Illustrated Parts Catalog Page Page Page Page Page Page Page Page