Manuals / Hearth and Home Technologies / Household Appliance / Electric Heater

Hearth and Home Technologies SL-550TRSI-AUE manual 1 2 3 4 5 6 7, Tabs

Models: SL-550TRSI-AUE

1 40

Download 40 pages 39.95 Kb

Page 27

Image 27

1.8LOG PLACEMENT INSTRUCTIONS Log Set Assembly: LOGS-550TRSI-AUE

1 2 3 4 5 6 7 8

TABS

CAUTION: Logs are fragile! Carefully remove the logs from the packaging.

LOG #1 (SRV550-715):Place log #1 onto the log grate so that the notches in the bottom of the log fit on the right three grate bars. Push log #1 towards the rear locating tabs.

LOG #2 (SRV347-703):Place log #2 so that its left edge sits against the left front grate corner and its right edge rests against the tab on the second grate bar.

Heat & Glo • SL-550TRSI-AUE • 2079-902 Rev. B • 7/06

Page 27

Image 27

Hearth and Home Technologies SL-550TRSI-AUE LOG PLACEMENT INSTRUCTIONS Log Set Assembly LOGS-550TRSI-AUE, 1 2 3 4 5 6 7

Contents

BY HOMEOWNER FOR OPERATION AND MAINTENANCE MODEL SL-550TRSI-AUEINSTALLATION AND OPERATION INSTRUCTIONS THIS MANUAL MUST BE USED FOR INSTALLATION AND RETAINEDMODEL SL-550TRSI-AUE TABLE OF CONTENTS Heat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/06 Figure 1. Diagram of SL-550TRSI-AUEMinimum Clearances from the Fireplace to Combustible Materials 1.0 INSTALLATION INSTRUCTIONSTop Flue Rear FlueFRAMING 1.1 INTRODUCTIONFigure 3. Framing Dimensions FLUEBelow eaves, balconies or other projections Horizontally from an openable window, door, non-mechanical airVertically below an openable window, non-mechanical air Space heatersIdentifying Flue Components 1.2 FLUE SYSTEM APPROVALSMODEL FLUE TERMINATION APPROVALSHeat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/06 NOTE PIPES OVERLAP 32mm AT EACH JOINTHeat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/06 NOTE PIPES OVERLAP 1 3/8 INCHES 35mm AT EACH JOINTUSE SL D-SERIES Vertical Flue RestrictorVERTICAL FLUEING 36 MAXIMUM 10.97MFT. M USE SL D-SERIES COMPONENTS ONLYFLUEING WITH ONE 1 90 ELBOW FT. MFT. M FLUEING WITH TWO 2 90 ELBOWSH + H FT. MH + H1 USE DVP-SERIESCOMPONENTS ONLY FLUEING WITH TWO 2 90 ELBOWSFT. M FLUEING WITH THREE 3 90 ELBOWSH + H FT. MV FT USE DVP-SERIESCOMPONENTS ONLY FLUEING WITH THREE 3 90 ELBOWSFlueing Out the Top Flue Installing Flue ComponentsFlueing Out the Rear Flue SYSTEM IS ATTACHED TO THE REAR STARTING COLLARS. SEE FIGURENENT AND THE OUTER HEATER WRAP Installing Flue ComponentsA. On the REAR of the heater 1. Attaching the First Flue Component to the Start- ing CollarsFigure 21. Seams Install Support Brackets3. Install Support Brackets PROCEED TO STEPFlue Pipe & Firestop 4. Install FirestopsFor Vertical Runs Figure 23. Installing Support BracketsFigure 28. Venting through the Wall C. Flue TerminationFigure 26. Ceiling Firestop Ceiling Side Figure 27. Attic FirestopFigure 29. Gas Supply Line 1.3 CONNECTING THE GAS SUPPLYShock Risk 1.4 IGNITION SYSTEM WIRINGBLUE BROWN GREEN/YELLOW 1.5 BLOWER FANBLOWER VARIABLE SPEED CONTROL BLACK BLACK 240VAC JUNCTION BOX1.6 FINISHING 1.7 INSTALLER TESTING Installing the TrimPilot Assembly 1.8 LOG PLACEMENT INSTRUCTIONS Log Set Assembly LOGS-550TRSI-AUE 1 2 3 4 5 6 7TABS LOG #3 SRV349-704 Position log #3 so that its right edge sits on log #1 as shown and its left edge sits on the first grate bar behind log #2 LOG #6 SRV550-718 Place log #6 on the base on front of the grate as shown WARNING THIS UNIT IS NOT FOR USE WITH SOLID FUEL 2.0 OPERATING INSTRUCTIONSOPERATING CAUTIONS TROL WIRING SYSTEM OF THIS UNITTO TURN OFF GAS TOAPPLIANCE 2.1 SAFETY & LIGHTING INFORMATIONFOR YOUR SAFETY READ BEFORE LIGHTING LIGHTING INSTRUCTIONSPilot Assembly 3.0 SERVICING AND MAINTENANCE2.2 FAN OPERATION GLASS DOOR WHEN IT IS HOT3.1 REMOVAL OF COVERS FOR SERVICING 3.2 REMOVAL OF COMPONENTS FOR SERVICE3.3 PARTS REPLACEMENT 3.4 ADJUSTMENTS AND REPLACEMENT PARTS3.5 MAINTENANCE TASKS Maintenance TasksDoors Inspect Possible Causes 3.6 TROUBLESHOOTINGSymptom Electronic Ignition SystemCorrective Actions SymptomElectronic Ignition System - continued Possible CausesSL-550TRSI-AUE Service Parts22 Log set assembly NG, LP Exploded Parts DiagramAccesssories SL-550TRSI-AUE Service Parts ListPage For Service or Replacement Parts Contact MelbournePerth Sydney