Manuals / Hearth and Home Technologies / Household Appliance / Electric Heater

Hearth and Home Technologies manual Diagram of SL-550TRSI-AUE

Models: SL-550TRSI-AUE

1 40

Page 4

		25-3/4 in.
		(653mm)
		12-7/8 in.
		(327mm)
	15-7/8 in.				16-3/8 in.
	(402mm)			8-3/4 in.	(414mm)
				8-3/4 in.
				(223mm)
			Ø 6-1/2 in.			Ø 82 in.
			(165mm)			Ø 82 in.
		36 in.	(165mm)			(203mm)
						(203mm)

		(913mm)
36-3/8 in.	32 in.
(924mm)	(813mm)			16-1/8 in.		32-5/8 in.
	2-1/8 in.			(408mm)		(828mm)
	(55mm)			3-1/2 in.
				(90mm)		23-3/8 in.
						23-3/8 in.
						(593mm)
GAS LINE		26-3/8 in.				ELECTRICAL
ACCESS		(671mm)				ELECTRICAL
6 in.		31-1/8 in.		6-7/8 in.		ACCESS
6 in.		31-1/8 in.		(175mm)
(153mm)		(790mm)
		TOP STANDOFFS
		FLUE COLLAR
		COVER PLATE
		HOOD
		DATA BADGE
		& LABELS
		DRESS
		GUARD
		ACCESS
		DOOR
		GAS
		CONTROLS
		ELECTRICAL
		ACCESS
		GAS LINE
		ACCESS
Figure 1. Diagram of SL-550TRSI-AUE
4	Heat & Glo • SL-550TRSI-AUE • 2079-902 Rev. B • 7/06

Page 4

Image 4

Hearth and Home Technologies manual Diagram of SL-550TRSI-AUE, Heat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/06

Contents

MODEL SL-550TRSI-AUE INSTALLATION AND OPERATION INSTRUCTIONSTHIS MANUAL MUST BE USED FOR INSTALLATION AND RETAINED BY HOMEOWNER FOR OPERATION AND MAINTENANCEMODEL SL-550TRSI-AUE TABLE OF CONTENTS Figure 1. Diagram of SL-550TRSI-AUE Heat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/061.0 INSTALLATION INSTRUCTIONS Top FlueRear Flue Minimum Clearances from the Fireplace to Combustible Materials1.1 INTRODUCTION Figure 3. Framing DimensionsFLUE FRAMINGHorizontally from an openable window, door, non-mechanical air Vertically below an openable window, non-mechanical airSpace heaters Below eaves, balconies or other projections1.2 FLUE SYSTEM APPROVALS MODELFLUE TERMINATION APPROVALS Identifying Flue ComponentsNOTE PIPES OVERLAP 32mm AT EACH JOINT Heat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/06NOTE PIPES OVERLAP 1 3/8 INCHES 35mm AT EACH JOINT Heat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/06Vertical Flue Restrictor VERTICAL FLUEING36 MAXIMUM 10.97M USE SL D-SERIESUSE SL D-SERIES COMPONENTS ONLY FLUEING WITH ONE 1 90 ELBOWFT. M FT. MFLUEING WITH TWO 2 90 ELBOWS H + HFT. M FT. MUSE DVP-SERIES COMPONENTS ONLYFLUEING WITH TWO 2 90 ELBOWS H + H1FLUEING WITH THREE 3 90 ELBOWS H + HFT. M FT. MUSE DVP-SERIES COMPONENTS ONLYFLUEING WITH THREE 3 90 ELBOWS V FTInstalling Flue Components Flueing Out the Rear FlueSYSTEM IS ATTACHED TO THE REAR STARTING COLLARS. SEE FIGURE Flueing Out the Top FlueInstalling Flue Components A. On the REAR of the heater1. Attaching the First Flue Component to the Start- ing Collars NENT AND THE OUTER HEATER WRAPInstall Support Brackets 3. Install Support BracketsPROCEED TO STEP Figure 21. Seams4. Install Firestops For Vertical RunsFigure 23. Installing Support Brackets Flue Pipe & FirestopC. Flue Termination Figure 26. Ceiling Firestop Ceiling SideFigure 27. Attic Firestop Figure 28. Venting through the Wall1.3 CONNECTING THE GAS SUPPLY Figure 29. Gas Supply Line1.4 IGNITION SYSTEM WIRING Shock Risk1.5 BLOWER FAN BLOWERVARIABLE SPEED CONTROL BLACK BLACK 240VAC JUNCTION BOX BLUE BROWN GREEN/YELLOW1.6 FINISHING Installing the Trim 1.7 INSTALLER TESTINGPilot Assembly 1 2 3 4 5 6 7 1.8 LOG PLACEMENT INSTRUCTIONS Log Set Assembly LOGS-550TRSI-AUETABS LOG #3 SRV349-704 Position log #3 so that its right edge sits on log #1 as shown and its left edge sits on the first grate bar behind log #2 LOG #6 SRV550-718 Place log #6 on the base on front of the grate as shown 2.0 OPERATING INSTRUCTIONS OPERATING CAUTIONSTROL WIRING SYSTEM OF THIS UNIT WARNING THIS UNIT IS NOT FOR USE WITH SOLID FUEL2.1 SAFETY & LIGHTING INFORMATION FOR YOUR SAFETY READ BEFORE LIGHTINGLIGHTING INSTRUCTIONS TO TURN OFF GAS TOAPPLIANCE3.0 SERVICING AND MAINTENANCE 2.2 FAN OPERATIONGLASS DOOR WHEN IT IS HOT Pilot Assembly3.2 REMOVAL OF COMPONENTS FOR SERVICE 3.3 PARTS REPLACEMENT3.4 ADJUSTMENTS AND REPLACEMENT PARTS 3.1 REMOVAL OF COVERS FOR SERVICINGMaintenance Tasks 3.5 MAINTENANCE TASKSDoors Inspect 3.6 TROUBLESHOOTING SymptomElectronic Ignition System Possible CausesSymptom Electronic Ignition System - continuedPossible Causes Corrective ActionsService Parts 22 Log set assemblyNG, LP Exploded Parts Diagram SL-550TRSI-AUESL-550TRSI-AUE Service Parts List AccesssoriesPage Melbourne PerthSydney For Service or Replacement Parts Contact

Figure 1. Diagram of SL-550TRSI-AUE

Heat & Glo • SL-550TRSI-AUE • 2079-902 Rev. B • 7/06