Manuals / Hearth and Home Technologies / Household Appliance / Electric Heater

Hearth and Home Technologies manual SL-550TRSI-AUE Service Parts List, Accesssories

Models: SL-550TRSI-AUE

1 40

Download 40 pages 39.95 Kb

Page 38

SL-550TRSI-AUE Service Parts List

SL-550TRSI-AUE Service Parts List

IMPORTANT: When ordering, supply serial and model numbers to ensure correct service parts.

	ITEM	PARTS	PART NUMBER
	1	Valve NG	2098-130
	1	Valve LP	2098-131
		Valve LP	2098-131
	2	Orifice NG	582-840
	2	Orifice LP	582-057
		Orifice LP	582-057
	3	Flexible Gas Connector	530-302A
	4	Burner Assembly NG	2079-010
	4	Burner Assembly LP	2079-012
		Burner Assembly LP	2079-012
	5	Ignition Cable	2098-147
	6	Hood	SRV550-175
	7	Glass Door Assembly	GLA-550TRS
	8	Dress Guard	2079-040
	9	Top Louver	550-251A
	10	Lower Door	2079-041
	11	Grate	2021-007
	12	Base Refractory	550-117
	13	Blower Assembly 240V	100-505A
	14	Junction Box	2078-025
	15	Power Cord	546-251A
	16	Pilot Assembly NG	2098-050
	16	Pilot Assembly LP	2098-051
		Pilot Assembly LP	2098-051
	17	Switch Assembly	2098-145
	18	Interior Top Heat Shield	2079-109
	19	Gas Shutoff Assembly	2078-022
	20	Rheostat	491-510A
	21	Switch Sensor	046-530
	22	Log Set Assembly	LOGS-550TRSAUD
	23	Log #1	SRV550-715
	24	Log #2	SRV347-703
	25	Log #3	SRV349-704
	26	Log #4	SRV278-705
	27	Log #5	SRV540-704
	28	Log #6	SRV550-718
	29	Log #7	SRV484-703
	30	Log #8	SRV347-701
	31	Valve Plate Gasket	530-431
	32	Pilot Bracket	2079-104
	33	Valve Bracket	2089-120
	34	Control Cable	2098-143
	35	Module, Maxitrol	2098-142
	36	240V Adaptor	2098-144
	37	Burner Neck Gasket	2045-407
	38	Rheostat Knob	100-512
	39	Thermocouple Block	2098-146
	40	Block Control Wire	2098-148
		Glass Latch Assembly	386-122A
		Mineral Wool	050-721
		Mesh Assembly	561-330A
		Exhaust Resistor	347-299
		Accesssories
		Wall Switch Kit, Off White	WSK-21
		Wall Switch Kit, White	WSK-21W
		Conversion Kit NG	NGK-550I-AUE
		Conversion Kit LP	LPK-550I-AUE

38	Heat & Glo • SL-550TRSI-AUE • 2079-902 Rev. B • 7/06

Image 38

Hearth and Home Technologies manual SL-550TRSI-AUE Service Parts List, Accesssories

Contents

THIS MANUAL MUST BE USED FOR INSTALLATION AND RETAINED MODEL SL-550TRSI-AUEINSTALLATION AND OPERATION INSTRUCTIONS BY HOMEOWNER FOR OPERATION AND MAINTENANCEMODEL SL-550TRSI-AUE TABLE OF CONTENTS Figure 1. Diagram of SL-550TRSI-AUE Heat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/06Rear Flue 1.0 INSTALLATION INSTRUCTIONSTop Flue Minimum Clearances from the Fireplace to Combustible MaterialsFLUE 1.1 INTRODUCTIONFigure 3. Framing Dimensions FRAMINGSpace heaters Horizontally from an openable window, door, non-mechanical airVertically below an openable window, non-mechanical air Below eaves, balconies or other projectionsFLUE TERMINATION APPROVALS 1.2 FLUE SYSTEM APPROVALSMODEL Identifying Flue ComponentsNOTE PIPES OVERLAP 32mm AT EACH JOINT Heat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/06NOTE PIPES OVERLAP 1 3/8 INCHES 35mm AT EACH JOINT Heat & Glo SL-550TRSI-AUE 2079-902 Rev. B 7/0636 MAXIMUM 10.97M Vertical Flue RestrictorVERTICAL FLUEING USE SL D-SERIESFT. M USE SL D-SERIES COMPONENTS ONLYFLUEING WITH ONE 1 90 ELBOW FT. MFT. M FLUEING WITH TWO 2 90 ELBOWSH + H FT. MFLUEING WITH TWO 2 90 ELBOWS USE DVP-SERIESCOMPONENTS ONLY H + H1FT. M FLUEING WITH THREE 3 90 ELBOWSH + H FT. MFLUEING WITH THREE 3 90 ELBOWS USE DVP-SERIESCOMPONENTS ONLY V FTSYSTEM IS ATTACHED TO THE REAR STARTING COLLARS. SEE FIGURE Installing Flue ComponentsFlueing Out the Rear Flue Flueing Out the Top Flue1. Attaching the First Flue Component to the Start- ing Collars Installing Flue ComponentsA. On the REAR of the heater NENT AND THE OUTER HEATER WRAPPROCEED TO STEP Install Support Brackets3. Install Support Brackets Figure 21. SeamsFigure 23. Installing Support Brackets 4. Install FirestopsFor Vertical Runs Flue Pipe & FirestopFigure 27. Attic Firestop C. Flue TerminationFigure 26. Ceiling Firestop Ceiling Side Figure 28. Venting through the Wall1.3 CONNECTING THE GAS SUPPLY Figure 29. Gas Supply Line1.4 IGNITION SYSTEM WIRING Shock RiskVARIABLE SPEED CONTROL BLACK BLACK 240VAC JUNCTION BOX 1.5 BLOWER FANBLOWER BLUE BROWN GREEN/YELLOW1.6 FINISHING Pilot Assembly 1.7 INSTALLER TESTINGInstalling the Trim TABS 1.8 LOG PLACEMENT INSTRUCTIONS Log Set Assembly LOGS-550TRSI-AUE1 2 3 4 5 6 7 LOG #3 SRV349-704 Position log #3 so that its right edge sits on log #1 as shown and its left edge sits on the first grate bar behind log #2 LOG #6 SRV550-718 Place log #6 on the base on front of the grate as shown TROL WIRING SYSTEM OF THIS UNIT 2.0 OPERATING INSTRUCTIONSOPERATING CAUTIONS WARNING THIS UNIT IS NOT FOR USE WITH SOLID FUELLIGHTING INSTRUCTIONS 2.1 SAFETY & LIGHTING INFORMATIONFOR YOUR SAFETY READ BEFORE LIGHTING TO TURN OFF GAS TOAPPLIANCEGLASS DOOR WHEN IT IS HOT 3.0 SERVICING AND MAINTENANCE2.2 FAN OPERATION Pilot Assembly3.4 ADJUSTMENTS AND REPLACEMENT PARTS 3.2 REMOVAL OF COMPONENTS FOR SERVICE3.3 PARTS REPLACEMENT 3.1 REMOVAL OF COVERS FOR SERVICINGDoors Inspect 3.5 MAINTENANCE TASKSMaintenance Tasks Electronic Ignition System 3.6 TROUBLESHOOTINGSymptom Possible CausesPossible Causes SymptomElectronic Ignition System - continued Corrective ActionsNG, LP Exploded Parts Diagram Service Parts22 Log set assembly SL-550TRSI-AUESL-550TRSI-AUE Service Parts List AccesssoriesPage Sydney MelbournePerth For Service or Replacement Parts Contact