PRODUCT FEATURES and GAS SPECIFICATIONS | HBDV7 Series Direct Vent Gas Fireplace |
PRODUCT SPECIFICATIONS
•This appliance has been certified for use with either natural or propane gas. Refer to appropriate data plates.
•This appliance is not for use with solid fuels.
•The appliance is approved for bedroom or bedsitting room installations.
•The appliance must be installed in accordance with local codes if any. If none exist use the current installation code. ANSI Z223.1/NFPA 54 in the USA, CSA B149 in Canada.
•This appliance is mobile home approved.
•The appliance must be properly connected to a venting system.
•The appliance is not approved for closet or recessed installations.
Hi/Lo Knob |
| |
Off/Pilot/On Knob |
| |
On/Off/RS Switch | FP2580 | |
| ||
Ignitor | Optional Remote | |
Figure 1 - | Receiver | |
Blower Control | ||
HBDV300/400 Fireplace | ||
|
HIGH ELEVATIONS
Input ratings are shown in BTU per hour and are certified without deration for elevations up to 4,500 feet (1,370 m) above sea level.
For elevations above 4,500 feet (1,370 m) in USA, installation must be in accordance with the current ANSI Z223.1/NFPA 54 and/or local codes having juris- diction.
In Canada, please consult provincial and/or local authorities having jurisdiction for installation at eleva- tions above 4,500 feet (1,370 m).
GAS pressures
| Natural | Propane (LP) |
Inlet Minimum | 4.5” w.c. | 11.0” w.c. |
Inlet Maximum | 10.5” w.c. | 13.0” w.c. |
Manifold Pressure | 3.5” w.c. | 10.0” w.c. |
Gas Specifications & ORIFICE SIZE
|
| Max.Input | Min. Input | Orifice |
Model | Fuel | BTU/h | BTU/h | Size |
HBDV300NV7 | Nat. | 23,000 | 16,000 | 2.35 mm |
HBDV300PV7 | LP | 23,000 | 18,000 | 1.50 mm |
HBDV400NV7 | Nat. | 27,000 | 19,000 | #41 |
HBDV400PV7 | LP | 26,000 | 20,000 | 1/16 |
HBDV300NSC7 | Nat. | 23,000 | 16,000 | 2.35 mm |
HBDV300PSC7 | LP | 23,000 | 18,000 | 1.50 MM |
HBDV400NSC7 | Nat. | 27,000 | 19,000 | #41 |
HBDV400PSC7 | LP | 26,000 | 20,000 | 1/16 |
|
|
|
|
|
Before You Start
Read this homeowner manual thoroughly and follow all instructions carefully. Inspect all contents for shipping damage and immediately inform your dealer if any damage is found. Do not install any unit with damaged, incomplete, or substitute parts. Check your packing list to verify that all listed parts have been received. You should have the following:
•Fireplace (Firebox and Burner System)
•Rock Wool
•Log Set
Items Required For Installation
• | Phillips Screwdriver | • | Framing Materials |
• | Hammer | • | Wall Finishing Materials |
• Saw and/or saber saw | • | Level | |
• Electric Drill and Bits | • | Tee Joint | |
• | Pliers | • | Measuring Tape |
• | Square | • | Pipe Wrench |
•Caulking Material (Noncombustible)
•Fireplace Surround Material (Noncombustible)
•Piping Complying with Local Codes
•Pipe Sealant Approved for use with Propane/LPG (Resistant to Sulfur Compounds)
54D8000
