Rubber Seals Assy | Multiquip DCA180SSJU manual

RUBBER SEALS ASSY.

RUBBER SEALS ASSY.

PAGE 100 — DCA-180SSJU — OPERATION AND PARTS MANUAL — REV. #3 (02/01/10)

Image 100

Multiquip DCA180SSJU operation manual Rubber Seals Assy

Contents

Parts List NO. M3870301004 Model DCA180SSJU 60HZ Generator Proposition 65 Warning Reporting Safety Defects Nhtsa MQ Power DCA-180SSJU Whisperwatttm Generator Table of Contents Parts Ordering Procedures Ordering parts has never been easier Specifications Generator Specifications Dimensions TOP, Side and Front Dimensions Conjunction with Safety Safety Message Alert SymbolsPotential hazards associated with the operation of this Protection Always wear approved protectionThis generator, other property General Safety Result causing severeRules for Safe Operation Drugs or alcohol Electrical Safety Generator Grounding Maintenance Safety Battery SafetyUse the following guidelines when handling the battery Avoid eye irritation DOT Towing & Transporting SafetyEmergencies Generator Decals Generator Decals Generator Decals Cont inued Installation Typical Generator Grounding Application Outdoor Installation Indoor InstallationWhen connecting the generator Mounting General Information Major Components Generator Major Components Menu Button Press this button to enter or exit menu screens Diagnostic DisplayDisplay Parameters Engine. Note Displays only when SAE J1939 First Time Start UpNext item down Main Menu Navigation Diagnostic Code Stored Fault CodesEngine Configuration Data To make a selection Diagnostic Display 24 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 Auxiliary Gage Fault Active Fault Codes Shut Down Codes Backlight AdjustmentDamage Intensity Contrast AdjustmentContrast is highlighted Setup 1- Up Display Select Units Once the Setup 1-up Display menu icon has been Up display function Automatic Scan on Select the 4-Up Custom Setup from the 4-Up Setup menu Setup 4-Up DisplayTouch the Enter Button and a list of parameters will appear Engine OIL Temperature Utilities 34 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 Menu Touch the Menu button again to return to the MainTouch the Menu Button Highlight it, then touch Enter Glossary Troubleshooting information ECU did not respond to the PowerView requestNo parameter selected for this 4- UP quadrant Press and hold the Menu button for approximately 3 seconds To restore power to Generator Control PanelButton on the overcurrent relay and place Circuit breaker Position on Engine Operating Panel Fuel Gauge Indicates amount of diesel fuel available Fault Auto On/Off Engine Controller MpecEngine by initializing Unit. This is considered a Are considered Output Terminal Panel FamiliarizationOutput Terminal Familiarization Removing the Plastic Face Plate Hard Wire Hookup Panel VAC Gfci ReceptaclesPressing Counter-clockwise will Voltage Connecting Loads Over Current Relay Single Phase Load Three Phase LoadSystem, amust install an Load Application Generator Outputs Generator Output VoltagesVoltage Change-Over Board Maximum Amps Generator OUTPUTS/ Gauge Reading AC Ammeter Gauge ReadingShow a reading when Are Output Terminal Panel Connections Uvwo Terminal Output Voltages3Ø-240V Uvwo Terminal Output Voltages 1Ø-240V Uvwo Terminal Output Voltages 3Ø-480 Uvwo Output Terminal Voltages Uwvo Output Terminal Lugs 1Ø-277V Connections Setup Circuit BreakersLubrication Oil Fuel Check ONLY! use Refueling ProcedureRefueling Cleaning the Radiator Air Cleaner Fan Belt TensionCoolant Antifreeze Operation Freezing Weather Battery Battery Cable InstallationWiring Alternator Before Starting Generator START-UP Procedure ManualStarting Manual OFF/RESET position Speed switch Starting Auto Mode When the generator is set Auto mode, the generator willOn position Figure Ammeter will Generator START-UP Procedure Auto Mode Normal Shutdown Procedure Generator SHUT-DOWN ProceduresOFF/RESET position Emergency Shutdown Procedure Maintenance Engine Cleaning the Fuel Strainer Air RemovalCheck Oil Level Replacing Oil Filter Commercial power to theand Maintenance HEATER/CHARGERTo ensure adequate starting Maintenance Trailer Trailer Maintenance Brake Adjustment BrakesHydraulic Surge Brakes Actuator Tire Wear/Inflation Tires/Wheels/Lug NutsSuspension Lug Nut Torque Requirements Use an pneumatic air Trailer Wiring Diagram Trailer/Towing Vehicle Wiring Diagram Generator Wiring Diagram Generator Wiring Diagram DCA-180SSJU Engine Wiring Diagram Engine Wiring Diagram Troubleshooting Generator Generator Troubleshooting Troubleshooting Engine Controller Engine Controller Troubleshooting Mpec DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 Sample Parts List Explanation of Code in Remarks Column Part number on this Suggested Spare Parts list Suggested Spare Parts Generator Assy C0110000602 06018423340601823282 0018205020 Control Panel Assy M4223000303 M4223000404022100100 022100165 Control BOX Assy M3213001302 06018096660027106018 0601870423 78 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 M4260500003 060220259229A 0030006000 0027106016 Engine and Radiator Assy Part Name QTY Remarks Engine and Radiator ASSY. Part Name Output Terminal Assy Output Terminal Assy M3230700113 M9220100914M9220101004 0039320000 86 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 M4260600104 25-1 0221001500019206020 0601812538 Battery Assy 0602220196 M9310500404M9103000504 0602220921 Muffler Assy M4330100502 0016910025M4333000303 0602325066 Fuel Tank Assy M4363000102 06055050700605501069 0605516090 Enclosure Assy Enclosure Assy M4413000302 M14134000040019208020 M4423000312 Enclosure ASSY. Enclosure ASSY. 0037906000 28A 0041206000M9113000002 0021806016 98 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 M4453001203 51A M4493403804M4453001303 52A M4493403904 Rubber Seals Assy 0229201240 02289009450228901200 0228901260 Nameplate and Decals Assy M4550000303 M9520100304M9520100603 M3550002702 Terms and Conditions of Sale Parts Freight Policy DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 HERE’S HOW to GET Help