0229201240, 0228900945, 0228901200 | Multiquip DCA180SSJU instruction

RUBBER SEALS ASSY.

RUBBER SEAL ASSY.
NO.	PART NO.	PART NAME	QTY.	REMARKS
1	0229201240	RUBBER SEAL	4
2	0228900945	RUBBER SEAL	4
3	0228901200	RUBBER SEAL	3
4	0228901260	RUBBER SEAL	3
5	0228901055	RUBBER SEAL	4
6	0228900600	RUBBER SEAL	1
7	0228900660	RUBBER SEAL	1
8	0229201060	RUBBER SEAL	1
9	0229200660	RUBBER SEAL	2
10	0228801050	RUBBER SEAL	2
11	0228800595	RUBBER SEAL	1
12	0228800635	RUBBER SEAL	1
13	0228100560	RUBBER SEAL	2
14	0228100370	RUBBER SEAL	2
15	0229201020	RUBBER SEAL	2
16	0229201200	RUBBER SEAL	2

DCA-180SSJU — OPERATION AND PARTS MANUAL — REV. #3 (02/01/10) — PAGE 101

Image 101

Multiquip DCA180SSJU 0229201240, 0228900945, 0228901200, 0228901260, 0228901055, 0228900600, 0228900660, 0229201060

Contents

Model DCA180SSJU 60HZ Generator Parts List NO. M3870301004 Proposition 65 Warning Nhtsa Reporting Safety Defects Table of Contents MQ Power DCA-180SSJU Whisperwatttm Generator Ordering parts has never been easier Parts Ordering Procedures Generator Specifications Specifications Dimensions Dimensions TOP, Side and Front Potential hazards associated with the operation of this Safety Message Alert SymbolsConjunction with Safety This generator, other property Always wear approved protectionProtection Result causing severe General SafetyRules for Safe Operation Drugs or alcohol Generator Grounding Electrical Safety Battery Safety Maintenance SafetyUse the following guidelines when handling the battery Avoid eye irritation Emergencies Towing & Transporting SafetyDOT Generator Decals Generator Decals Generator Decals Cont inued Typical Generator Grounding Application Installation Indoor Installation Outdoor InstallationWhen connecting the generator Mounting General Information Generator Major Components Major Components Display Parameters Diagnostic DisplayMenu Button Press this button to enter or exit menu screens First Time Start Up Engine. Note Displays only when SAE J1939Next item down Main Menu Navigation Stored Fault Codes Diagnostic CodeEngine Configuration Data To make a selection Diagnostic Display 24 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 Auxiliary Gage Fault Active Fault Codes Damage Backlight AdjustmentShut Down Codes Contrast is highlighted Contrast AdjustmentIntensity Select Units Setup 1- Up Display Up display function Once the Setup 1-up Display menu icon has been Automatic Scan on Touch the Enter Button and a list of parameters will appear Setup 4-Up DisplaySelect the 4-Up Custom Setup from the 4-Up Setup menu Utilities Engine OIL Temperature 34 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 Touch the Menu Button Highlight it, then touch Enter Touch the Menu button again to return to the MainMenu ECU did not respond to the PowerView request Glossary Troubleshooting informationNo parameter selected for this 4- UP quadrant Press and hold the Menu button for approximately 3 seconds Generator Control Panel To restore power toButton on the overcurrent relay and place Circuit breaker Position on Fuel Gauge Indicates amount of diesel fuel available Engine Operating Panel Auto On/Off Engine Controller Mpec FaultEngine by initializing Unit. This is considered a Output Terminal Familiarization Output Terminal Panel FamiliarizationAre considered VAC Gfci Receptacles Removing the Plastic Face Plate Hard Wire Hookup PanelPressing Counter-clockwise will Voltage Over Current Relay Connecting Loads Three Phase Load Single Phase LoadSystem, amust install an Load Application Generator Output Voltages Generator OutputsVoltage Change-Over Board Maximum Amps AC Ammeter Gauge Reading Generator OUTPUTS/ Gauge ReadingShow a reading when Are Uvwo Terminal Output Voltages Output Terminal Panel Connections3Ø-240V Uvwo Terminal Output Voltages 1Ø-240V Uvwo Terminal Output Voltages Uwvo Output Terminal Lugs 1Ø-277V Connections 3Ø-480 Uvwo Output Terminal Voltages Circuit Breakers SetupLubrication Oil Fuel Check Refueling Refueling ProcedureONLY! use Air Cleaner Fan Belt Tension Cleaning the RadiatorCoolant Antifreeze Operation Freezing Weather Battery Cable Installation BatteryWiring Alternator Starting Manual Generator START-UP Procedure ManualBefore Starting Speed switch OFF/RESET position When the generator is set Auto mode, the generator will Starting Auto ModeOn position Figure Ammeter will Generator START-UP Procedure Auto Mode OFF/RESET position Emergency Shutdown Procedure Generator SHUT-DOWN ProceduresNormal Shutdown Procedure Maintenance Engine Air Removal Cleaning the Fuel StrainerCheck Oil Level Replacing Oil Filter To ensure adequate starting Maintenance HEATER/CHARGERCommercial power to theand Trailer Maintenance Maintenance Trailer Brakes Brake AdjustmentHydraulic Surge Brakes Actuator Suspension Tires/Wheels/Lug NutsTire Wear/Inflation Use an pneumatic air Lug Nut Torque Requirements Trailer/Towing Vehicle Wiring Diagram Trailer Wiring Diagram Generator Wiring Diagram Generator Wiring Diagram Engine Wiring Diagram DCA-180SSJU Engine Wiring Diagram Generator Troubleshooting Troubleshooting Generator Engine Controller Troubleshooting Mpec Troubleshooting Engine Controller DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 Explanation of Code in Remarks Column Sample Parts List Suggested Spare Parts Part number on this Suggested Spare Parts list Generator Assy 0601842334 C01100006020601823282 0018205020 Control Panel Assy M4223000404 M4223000303022100100 022100165 Control BOX Assy 0601809666 M32130013020027106018 0601870423 78 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 0602202592 M426050000329A 0030006000 0027106016 Engine and Radiator Assy Part Name QTY Remarks Engine and Radiator ASSY. Part Name Output Terminal Assy Output Terminal Assy M9220100914 M3230700113M9220101004 0039320000 86 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 25-1 022100150 M42606001040019206020 0601812538 Battery Assy M9310500404 0602220196M9103000504 0602220921 Muffler Assy 0016910025 M4330100502M4333000303 0602325066 Fuel Tank Assy 0605505070 M43630001020605501069 0605516090 Enclosure Assy Enclosure Assy M1413400004 M44130003020019208020 M4423000312 Enclosure ASSY. Enclosure ASSY. 28A 0041206000 0037906000M9113000002 0021806016 98 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 51A M4493403804 M4453001203M4453001303 52A M4493403904 Rubber Seals Assy 0228900945 02292012400228901200 0228901260 Nameplate and Decals Assy M9520100304 M4550000303M9520100603 M3550002702 Freight Policy Terms and Conditions of Sale Parts DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 HERE’S HOW to GET Help