Manuals / Subaru Robin Power Products / Lawn and Garden / Portable Generator

Subaru Robin Power Products R1700i service manual Improper revolutions Electronic throttle

Models: R1700i

1 52

Page 46

Improper revolutions (Electronic throttle)

			Improper revolutions (Electronic throttle)
			Yes
Starts but			Yes
stops suddenly				Go to the "Engine does not start (Start failure)"
				Go to the "Engine does not start (Start failure)"


	No
			Yes

・Engine revolution				Confirm connection of
does not increase				Confirm connection of
does not increase				electronic throttle part
・Hunting				electronic throttle part
・Hunting

					OK
						Does


		・Pull the recoil lightly with the carburetor throttle fully opened not run

Full throttle direction ：Towards the opposite direction against the

air cleaner in front.

Runs

・Dirty or bad spark plug ・Poor return of the choke ・Air cleaner blockage ・Muffler blockage

・Bad carburetor (water leak-in, blockage, etc.) ・Lack of gasoline

・Gasoline corrosion

・Blockage from the tank to the carburetor

Change the stepping motor or carburetor

– 43 –

Page 46

Image 46

Subaru Robin Power Products R1700i service manual Improper revolutions Electronic throttle

Contents

Model R1700i GENERATORPUB-GS1950Rev. 09/04 Page CONTENTS MODEL 1. SPECIFICATIONSR1700i 2. GENERAL DESCRIPTION 2-1EXTERNAL VIEW R1700i2-2CONTROL PANEL R1700i 1 ENGINE SWITCH3 OIL SENSOR LAMP 4AUTO POWER SAVE SWITCH2 PILOT LAMP and OVERLOAD LAMP PILOT LAMP6 DC TERMINALS 5 AC RECEPTACLES7DC CIRCUIT BREAKER R1700i 2-4GENERATOR ASSEMBLYSerial number and Production number Label 3. RANGE OF APPLICATIONS 3Mercury lamps with a smaller power factorPage Page 4. MEASURING AND CHECKING PROCEDURES 4-1INSTRUMENTS5MEAGER TESTER 4CIRCUIT TESTER For measuring resistance, etc6TACHOMETER MODEL Dr.RobinSpecification 4-2AC OUTPUT MEASURING4-3MEASURING INSULATION RESISTANCE ModelPage 4-4CHECKING FUNCTIONAL MEMBERS Page Below the lower level ON continuity Oil capacity 0.4 liters5-1PRECAUTIONS 5. ASSEMBLY AND DISASSEMBLY5-2SPECIAL TOOLS – 19 – 5-3DISASSEMBLY PROCEDURES5-3-3Remove rolling wire, choke wire 5-3-1Remove the side panels Left, Right5-3-6Remove the case body Left, Right 5-3-4Remove the recoil starter handle5-3-5Remove the control panel Upper part of the case body5-3-8Remove fuel cock bracket 5-3-7Remove rear frame5-3-9Remove the fuel tank 5-3-11Remove the inverter unit 5-3-10Remove the control panel5-3-12Remove the fuel pipes 5-3-14Remove the front frame 5-3-13Remove the air cleaner and carburetor5-3-15Remove the base inverter 5-3-16Remove the Stator / Rear cover 5-3-17Remove the rotor5-3-19Remove the flywheel 5-3-18Remove Blower housing5-3-20Remove recoil starter 5-3-22Remove the ignition coil 5-3-21Remove the muffler5-3-23Remove the cylinder baffle Tightening torque 5-4REASSEMBLY PROCEDURES5-4-1Cylinder baffle 70-905.2-6.6ft・lbs 5-4-5Flywheel 5-4-4Recoil starterTightening torque 7.0-9.0N・m 70-90kgf・cm Air gap 0.5 mmTightening torque 3.0-5.0N・m 30-50kgf・cm 5-4-8Blower housing5-4-7Pulsar coil and grommet 2.2-3.7ft・lbs5-4-9Rotor 5-4-10Rear cover, stator5-4-11Base Inverter 5-4-13Air cleaner bottom plate and carburetor5-4-14Air cleaner Tightening torque5-4-15Fuel pipe 5-4-17Installing coupler5-4-16Inverter unit 5-4-19Fuel cock bracket 5-4-18Fuel tank5-4-20Rear frame 5-4-21Case body, control panel 5-4-22Recoil starter and guideTightening torque 5-4-23Choke wire and rolling wire5-4-24Rear cover 30-405-5RECOIL STARTER 1 Disassembly proceduresPage 2 Assembly procedure – 38 –Page 3 Checking items after assembly 4 When 6.TROUBLESHOOTING No output power or Lower outputImproper revolutions Electronic throttle Engine does not start Start failure Spark Plug - BMR4A NGKWiring color cord 7. WIRING DIAGRAMR1700i 50Hz-230V Wiring color cord R1700i 50Hz-240VWiring color cord R1700i 60Hz-120VPage Copyright 2004 Robin America, Inc

Improper revolutions (Electronic throttle)

– 43 –