Outback Power Systems manual Reading the FLEXnet DC, Postion wiring block

Page 7

Reading the FLEXnet DC

RJ45 jack connects to

Port 2 or higher in HUB

LEDs*

1

2

3

4

5

6

7

8

9

10

(GREEN)

(YELLOW)

(YELLOW)

(YELLOW)

(RED)

SOC >90% 80-89% 70-79% 60-69% 50-59%

ON

OFF

Blinking green LED: Charge parameters met

Solid green LED: SOC** is above 90%

Solid red LED: SOC is greater than 49% but less than 60%

Off red LED: SOC is above 59%

Blinking red LED: SOC is less than 50%

*See page 15 **State of Charge

10-postion wiring block

1:BAT-

2:BAT+

3. Relay

4. Relay

5:C DEVICE SIDE

6:C BAT (-) SIDE

7:B DEVICE SIDE

8:B BAT (-) SIDE

9:A DEVICE SIDE

10:A BAT (-) SIDE

BAT+/- must connect directly to battery terminals of the bank being monitored.

Proper polarity must be observed on all connections.

6

Image 7
Contents NetTM DC About OutBack Power Systems WarrantyFLEXnet DC User’s Guide 2007 All rights reserved January DisclaimerDate and Revision Contact InformationTable of Contents Introduction OutBack Power Systems FLEXnet DCSystem Overview Reading the FLEXnet DC Postion wiring blockFLEXNet DC package includes Installing the FLEXnet DCConnect each twisted pair to a shunt Torque Values Wiring Block ConnectionsWhite to BAT Black to BAT + Installing the FLEXnet DC Maximum amp charged Maximum battery voltageFLEXNet DC Measurements KiloWattsLogged Data User Adjustable Set PointsData Logging Programming and Using the Mate for FLEXNet DC Operations Typical charge cycle All unused channels should be set to disabledFLEXNet DC Modes Charge CycleGreen Yellow RED Invert Logic Hi Set Point Satisfied Auto ModeProgramming the Auxiliary Relay Relay LogicMate Screens Readings Press the DC soft key to view the status of the FlexNet DCDown Status STATUS/FN Stats Meter Shunt Batt TOP STATUS/DC/SHUNT a Down UP Reset Down UP Reset TOP STATUS/DC/BATT UP TOP Status ADV BAT Shunt PG2 Press the ADV soft key Press the DC soft key Press the Charge soft keyPG1 Charge AUX PG3 ADV/DC/AUX Control ADV/DC/AUX SOC LOW PG2 Reset CLR Main Technical Notes Battery Charge Factor BCFFLEXnet Products Year Limited WarrantyRevision.2007-08-29 Outback Power Systems Inc 19009 62nd Ave. NE Limited Warranty RegistrationREV B