Weber 56576, Summit Gas Grill manual General Instructions

Page 7
GENERAL INSTRUCTIONS

GENERAL INSTRUCTIONS

With the Weber® gas barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances.. The closed lid and Flavorizer® bars produce that “outdoor” flavor in the food..

The natural gas supply is easy to use and gives you more cooking control than charcoal fuel..

•These instructions will give you the minimum requirements for assembling your Weber® gas barbecue.. Please read the instructions carefully before using your Weber® gas barbecue.. Improper assembly can be dangerous..

•Not for use by children..

•If there are local codes that apply to portable gas grills, you will have to conform to them.. Installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223..1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149..1, or Propane Storage and Handling Code, B149..2, or the Standard for Recreational Vehicles, ANSI A 119..2/NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable..

•This Weber® gas barbecue is designed for natural (piped in city) gas only.. Do not use liquid propane (LP) bottled gas.. The valves, orifices and hose are for natural gas only..

•Do not use with charcoal fuel..

•Check that the area under the control panel and the grease tray are free from debris that might obstruct the flow of combustion or ventilation air.. ◆

CANADIAN INSTALLATION

These instructions, while generally acceptable, do not necessarily comply with the Canadian Installation codes, particularly with piping above and below ground.. In Canada the installation of this appliance must comply with local codes and/or Standards CAN/ CGA-B149..1 (Installation Code for Natural Gas Burning Appliances and Equipment).. ◆

STORAGE AND/OR NONUSE

•The gas must be turned off at the natural gas supply when the Weber® gas barbecue is not in use..

•When the Weber® gas barbecue is stored indoors, the gas supply must be disconnected..

•The Weber® gas barbecue should be checked for gas leaks and any obstructions in the burner tubes before using.. (Refer to: “MAINTENANCE/ANNUAL MAINTENANCE”)..

•Check that the areas under the control panel and the slide out grease tray are free from debris that might obstruct the flow of combustion or ventilation air..

•The Spider/Insect screens should also be checked for any obstructions.. (Refer to: “MAINTENANCE/ANNUAL MAINTENANCE”).. ◆

OPERATING

mWARNING: Only use this barbecue outdoors in a well- ventilated area. Do not use in a garage, building, breezeway or any other enclosed area.

mWARNING: Your Weber® gas barbecue shall not be used under overhead combustible construction.

mWARNING: Your Weber® gas barbecue is not intended to be installed in or on recreational vehicles and/or boats.

mWARNING: Do not use the barbecue within 24 inches of combustible materials. This includes the top, bottom, back or sides of the grill.

mWARNING: The entire cookbox gets hot when in use. Do not leave unattended.

mWARNING: Keep any electrical supply cord and the fuel supply hose away from any heated surface.

mWARNING: Keep the cooking area clear of flammable vapors and liquids, such as gasoline, alcohol, etc., and combustible materials. ◆

GAS SUPPLY TESTING

•Disconnect your Weber® gas barbecue when the gas supply is being tested at high pressures.. This appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressures in excess of 1/2 psig (3..5 kPa)..

•Turn off your Weber® gas barbecue when the gas supply is being tested at low pressures.. This appliance must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at the pressure equal to or less than 1/2 psig (3..5 kPa).. ◆

NOTE: IF YOU HAVE PURCHASED A SIDEBURNER

If you have purchased a Side Burner accessory with your Summit® gas grill, Weber® recommends that you read the SUMMIT® BUILT-IN SIDEBURNER INSTALLATION/ OWNER’S GUIDE before designing your “island” structure.. ◆

www.weber.com® 7

Page 6 Page 8
Image 7
Page 6 Page 8
Contents 460 - NG GAS GRILL#56576 Built-In Natural Gas Grill Owner’s GuideWARNINGS TABLE OF CONTENTS SUMMIT BI 460NGUS111710 EXPLODED VIEWEXPLODED VIEW LIST 1890 Roselle Road, Suite Schaumburg, IL USA WARRANTYWEBER-STEPHEN PRODUCTS CO Customer Service Center For replacement parts callGENERAL INSTRUCTIONS Test Connections GAS INSTRUCTIONSGeneral Specifications for Piping Gas Line PipingCheck that all burner valves are off WHAT IS NATURAL GAS?TYPE OF GAS LEAK CHECK PREPARATIONCHECK FOR GAS LEAKS m DANGER Check Reinstall Control PanelLIGHTED CONTROL KNOBS LIGHT FEATURESBEFORE USING YOUR GRILL WEBER GRILL OUT HANDLE LIGHTm Always open the lid before igniting the burners SNAP IGNITION OPERATIONMain Burner Snap Ignition MAIN BURNER IGNITION & USAGEMAIN BURNER IGNITION & USAGE APAGADO ARRÊTÉ GRILLING TIPS & HELPFUL HINTS1 OFF 4 BURNER DIRECT METHOD COOKING METHODSDIRECT COOKING INDIRECT COOKINGAdjacent Main Burner Snap Ignition SEAR STATION IGNITION & USAGE4 BURNER SEAR METHOD Smoker Burner Snap Ignition SMOKER BURNER IGNITION & USAGESMOKER BURNER IGNITION & USAGE Before each use, empty the smoker of ash to allow proper air flow Rotisserie Burner Snap Ignition ROTISSERIE BURNER IGNITION & USAGEROTISSERIE BURNER IGNITION & USAGE IMPORTANT SAFEGUARDS ROTISSERIE FORK STORAGE ROTISSERIE COOKINGconjunction with the smell of gas This is normal for TROUBLESHOOTINGSymptoms Burners burn with a yellow or orange flame, inSear Station burner does not light SEAR STATION TROUBLESHOOTINGROTISSERIE TROUBLESHOOTING GRILL OUT HANDLE LIGHT TROUBLESHOOTINGMAINTENANCE scratched on the next step REPLACING MAIN BURNERS132 143 71 82m CAUTION The burner openings 12 must be positioned Inspection And Cleaning Of The Spider/Insect Screens ANNUAL MAINTENANCEBurner Flame Pattern Guía del propietario de la barbacoa empotrada de gas natural BARBACOA DE GASADVERTENCIAS ÍNDICE DIAGRAMA DE DESPIECE 43. Ensamble del espetón del asador giratorio LISTA DEL DIAGRAMA DE DESPIECESoporte del respiradero posterior Moldura decorativa de la perilla pequeñaColonia Americana 44160 México, C.P. México GARANTÍAPara partes de repuesto llame a INSTRUCCIONES GENERALES Pruebe las conexiones INSTRUCCIONES SOBRE EL GASEspecificaciones generales para la tubería Tubería de la línea de gasVerifique que todas las válvulas de los quemadores estén cerradas TIPO DE GAS¿QUÉ ES EL GAS NATURAL? PREPARATIVOS PARA LA BÚSQUEDA DE FUGASDETECCIÓN DE FUGAS DE GAS m PELIGRO puede tener ligeras VerifiqueVuelva a instalar el panel de control La barbacoa ilustradaPERILLAS DE CONTROL ILUMINADAS ILUMINACIÓNANTES DE UTILIZAR LA BARBACOA LÁMPARA DEL ASA WEBER GRILL OUTm Siempre abra la tapa antes encender los quemadores OPERACIÓN DEL ENCENDIDO DE CHASQUIDOEncendido rápido del quemador principal ENCENDIDO Y USO DEL QUEMADOR PRINCIPALENCENDIDO Y USO DEL QUEMADOR PRINCIPAL 1 FUEGO ALTO CONSEJOS PRÁCTICOS PARA ASAR4 Quemadores MÉTODO DIRECTO MÉTODOS DE COCCIÓNCOCCIÓN DIRECTA COCCIÓN INDIRECTAEncendido de acción rápida del quemador principal adyacente ENCENDIDO Y USO DE LA ESTACIÓN DE DORADO4 QUEMADORES MÉTODO PARA DORAR Encendido rápido del quemador del ahumador ENCENDIDO Y USO DEL QUEMADOR DEL AHUMADORENCENDIDO Y USO DEL QUEMADOR DEL AHUMADOR El ahumador usa astillas de madera premojadas.. Para resultados óptimos con alimentos Encendido rápido del quemador del asador giratorio ENCENDIDO Y USO DEL QUEMADOR DEL ASADOR GIRATORIOENCENDIDO Y USO DEL QUEMADOR DEL ASADOR GIRATORIO A Enchufe el cordón eléctrico en la fuente de alimentación eléctrica ALMACENAJE DE LA HORQUILLA DEL ASADOR GIRATORIO COCCIÓN CON EL ASADOR GIRATORIOconjuntamente con olor a gas esto RESOLUCIÓN DE PROBLEMASLa llama en los quemadores es de color amarillo o anaranjadoLos quemadores están quemando RESOLUCIÓN DE PROBLEMAS DE LA ESTACIÓN DE DORADORESOLUCIÓN DE PROBLEMAS DEL ASADOR GIRATORIO RESOLUCIÓN DE PROBLEMAS DE LA LUZ DEL ASA GRILL OUTMANTENIMIENTO REEMPLAZO DE LOS QUEMADORES PRINCIPALES m PRECAUCIÓN Los agujeros del quemador 12 deben A Tubo quemador MANTENIMIENTO ANUALInspección y limpieza de la malla contra arañas y demás insectos Patrón de la llama del quemadorManuel de l’utilisateur du grill au gaz naturel intégré GRILL A GAZMISES EN GARDE TABLE DES MATIERES VUE ECLATEE Panneau d’alignement de la roue arrière LISTE DE LA VUE ECLATEEAssemblage de la broche de la rôtissoire WEBER-STEPHEN PRODUCTS CO Product Registration P.O. Box GARANTIEBurlington, ON L7P 4W1 Pour des pièces de rechange, appelez le GENERALITES Tester les raccords INSTRUCTIONS RELATIVES AU GAZCaractéristiques techniques générales de la canalisation Canalisation de la conduite de gazVerifiez que toutes les valves du bruleur sont fermees TYPE DE GAZQU’EST-CE QUE LE GAZ NATUREL ? PREPARATION DE LA DETECTION DES FUITESDETECTION DES FUITES DE GAZ m DANGER Vérifiez Remise en place du panneau de commandede l’illustration présente LAMPE DE POIGNEE WEBER GRILL OUT FONCTIONNALITES D’ECLAIRAGEAVANT D’UTILISER VOTRE GRILL BOUTONS DE COMMANDES ECLAIRESm Ouvrez toujours le couvercle avant d’allumer les brûleurs UTILISATION DE L’ALLUMAGE A DECLICBouton d’allumage du bruleur principal ALLUMAGE & UTILISATION DU BRULEUR PRINCIPALIl est possible que le grill ARRÊTÉMARCHE CONSEILS & ASTUCES POUR LA GRILLADE4 BRÛLEURS CUISSON DIRECTE METHODES DE CUISSONCUISSON DIRECTE CUISSON INDIRECTEAllumage automatique des bruleurs principaux adjacents ALLUMAGE & UTILISATION DE LA SEAR STATIONAllumage automatique du bruleur principal adjacent 4 BRÛLEURS MÉTHODE POUR SAISIR LES ALIMENTSALLUMAGE & UTILISATION DU BRULEUR DU FUMOIR ALLUMAGE & UTILISATION DU BRULEUR DU FUMOIR à se consumer, positionnez le bouton de commande sur FAIBLE Bouton d’allumage du bruleur de la rotissoire ALLUMAGE & UTILISATION DU BRULEUR DE LA ROTISSOIREALLUMAGE & UTILISATION DU BRULEUR DE LA ROTISSOIRE A Branchez le cordon d’alimentation électrique sur une source de courant RANGEMENT DES FOURCHES DE LA ROTISSOIRE CUISINER AVEC LA ROTISSOIREodeur de gaz se dégage C’est DEPANNAGELes brûleurs produisent une flamme jaune ou orange, et uneLes brûleurs ont une flamme DEPANNAGE DE LA SEAR STATIONDEPANNAGE DE LA ROTISSOIRE DEPANNAGE DE L’ECLAIRAGE DE POIGNEE GRILL OUTlavez à l’eau savonneuse chaude, avant de rincer Ceci protègera le panneau de commandes ainsi que les dessus des REMPLACEMENT DES BRULEURS PRINCIPAUXportes contre les rayures lors de l’étape suivante m ATTENTION Les orifices du brûleur 12 doivent être Inspection et nettoyage de la grille anti-araignées/insectes MAINTENANCE ANNUELLEAspect des flammes du brûleur MEMO MEMO MEMO WEBER-STEPHEN PRODUCTS CO #56584 Built-In NG Gas Grill Installation GuideAssembly - Pg Gas GrillWARNINGS Summit 4-burner/6-burner grill BUILT-IN CUTOUT DIMENSIONS“ISLAND” STRUCTURE CONFIGURATION OPTIONS Note Gas Line LimitationLOCATING YOUR GRILL Grill and enclosure illustrations are for reference only BUILT-IN CUTOUT DETAILED DIMENSIONSb c d 460 - 8 660 Catch Pan Holder PARTS LIST LISTA DE PIEZAS LISTE DES PIECESBattery Housing 460 - 2 660 Flavorizer BarsTOOLS NEEDED HERRAMIENTAS REQUERIDAS OUTILS NECESSAIRES ASSEMBLY ENSAMBLAJE ASSEMBLAGEASSEMBLY ENSAMBLAJE ASSEMBLAGE Nécessite 3 piles alcalines “D” fournies. Utilisez des piles alcalines uniquement. Ne mélangez pas des piles usagées avec des piles neuves ou différents types de piles standard, alcalines ou rechargeables ASSEMBLY ENSAMBLAJE ASSEMBLAGE ASSEMBLY ENSAMBLAJE ASSEMBLAGE ASSEMBLY ENSAMBLAJE ASSEMBLAGE Now that the side vents are installed, the grill should be placed Remove two screws and two washers from back panel and set aside. Do not discard hardware ASSEMBLY ENSAMBLAJE ASSEMBLAGE Gire las ruedas delanteras de manera que las puntas de las ASSEMBLY ENSAMBLAJE ASSEMBLAGERotate front casters so that caster points a are facing the front of the grillTemporarily install the front wheel alignment panel using just one screw on each side Roll grill straight back into enclosure Reinstall the Front Wheel Alignment Panel securing both sides with all four screws ASSEMBLY ENSAMBLAJE ASSEMBLAGE 460660 ASSEMBLY ENSAMBLAJE ASSEMBLAGE BUILT-IN GAS LINE LOCATIONS GAS SUPPLYTYPICAL NATURAL GAS SUPPLY INSTALLATION If you have any questions, contact Customer Service at1 1/2 1 1/42 1/2 Gas line and regulator connected GAS SUPPLY CONNECTIONCONNECTION CHART Side viewVENTILATION Guía de instalación de las barbacoas de gas natural empotradas Barbacoa de GasEnsamblaje - Pg ADVERTENCIAS Quemador lateral accesorio opcional DIMENSIONES DEL CORTE DEL EMPOTRAMIENTOOPCIONES DE CONFIGURACIÓN DE LAS ESTRUCTURAS DE LAS “ISLAS” Nota Limitación de la línea de gasUBICACIÓN DE LA BARBACOA DIMENSIONES GENERALES DEL CORTE DEL EMPOTRADOSEPARACIONES DETALLES GENERALES DE LA CONSTRUCCIÓN DIMENSIONES DETALLADAS DEL CORTE DEL EMPOTRADOUBICACIONES DE LAS LÍNEAS DE GAS EMPOTRADAS SUMINISTRO DE GASSUMINISTRO DE GAS Tapa quemador lateral opcional CONEXIÓN DEL SUMINISTRO DE GASCONECTAR EL SUMINISTRO DE GAS CUADRO DE CONEXIONESVENTILACIÓN MEMO Assemblage - Pg Guide pour l’installation du grill à gaz naturel intégréMISES EN GARDE OPTIONS POUR LA CONFIGURATION DE LA STRUCTURE EN “ILOT” DIMENSIONS POUR LA DECOUPE D’ENCASTRAGERemarque Limitation concernant la conduite de gaz DIMENSIONS GENERALES POUR LA DECOUPE D’ENCASTRAGE CHOISIR L’EMPLACEMENT DE VOTRE GRILLESPACES DEGAGES GENERALITES SUR LA CONSTRUCTION DIMENSIONS DETAILLEES POUR LA DECOUPE D’ENCASTRAGEEMPLACEMENTS POUR LA CONDUITE DE GAZ INTEGREE ARRIVEE DE GAZPour toute question, veuillez contacter le Service clientèle au ARRIVEE DE GAZ Cache brûleur latéral en option CONNEXION A L’ARRIVEE DE GAZTABLEAU DE CONNEXION Arrivée de gaz à canalisation rigideLes aérations devraient être situées des deux côtés de la structure Remarque Ces schémas ne sont fournis qu’à titre de référenceMEMO MEMO WEBER-STEPHEN PRODUCTS LLC
Related manuals
Manual 100 pages 27.88 Kb
Top Page Image Contents