Invacare M71 service manual Reference Documents, Document Part Number

Page 2

REFERENCE DOCUMENTS

WARNING

DO NOT OPERATE THIS EQUIPMENT WITHOUT FIRST READING AND UNDERSTANDING THIS MANUAL. IF YOU ARE UNABLE TO UNDERSTAND THE WARNINGS, CAUTIONS, AND INSTRUCTIONS, CONTACT A HEALTHCARE PROFESSIONAL, DEALER OR A QUALIFIED TECHNICIAN BEFORE ATTEMPTING TO USE THIS EQUIPMENT - OTHERWISE INJURY OR DAMAGE MAY RESULT.

PROCEDURES OTHER THAN THOSE DESCRIBED IN THIS MANUAL MUST BE PERFORMED BY A QUALIFIED TECHNICIAN.

IF WHEELCHAIR IS EQUIPPED WITH POWER TILT ONLY OR THE FORMULA PTO PLUS SEATING SYSTEM, REFER TO POWER TILT ONLY FOR PRONTO M71 AND M91 OWNER’S MANUAL, PART NUMBER 1118362 OR TO FORMULA PTO PLUS POWERED SEATING SERVICE MANUAL, PART NUMBER 1125031 TO PERFORM THE FOLLOWING PROCEDURES:

•TILTING THE SEAT ASSEMBLY (REPLACES REMIVNG/ INSTALLING THE SEAT ASSEMBLY IN THIS MANUAL)

•ADJUSTING SEAT HEIGHT

•ADJUSTING SEAT POSITION

•CHARGING THE BATTERIES

REFERENCE DOCUMENTS

	DOCUMENT	PART NUMBER

M71 with MK5™Owners Manual BEFORE 1/24/06		1106631

M71 with MK5 Owners Manual AFTER 1/23/06		1141449

MK5	EX™Electronics Owners Manaul	1114808

MK5	NX™Electronics Owners Manual	1110532

MK6i™Field Reference Guide		1141471

MK6i Service Manual		1143203

MKIV™RII Electronics Owners Manual		1095272

M71 Base with MK6i Owners Manual		1143240

NOTE: Updated versions of this manual are available on www.invacare.com.

Pronto® M71™

2

Part No 1118377

Image 2

Contents Pronto M71 Document Part Number Reference DocumentsReference Documents Table of Contents Seat Assembly Removing/Installing the Adjustable Height TubesArms WheelsMotors Front RIGGINGS/FOOTBOARDSHROUDS/FRAME Controller and Joystick Limited WarrantyBATTERIES/CHARGER DISASSEMBLING/ASSEMBLING the M71Seat Positioning Strap Signal Word MeaningSpecial Notes Trro and Trbkts Warnings Wiring Label on M71 Standard with Battery Covers Label LocationsOne of these battery wiring Labels is in this location M71 with PTO+ Labels Inch VAN Asba Typical Product ParametersTypical Product Parameters Operation Information Repair or Service InformationGeneral Guidelines Batteries Tire PressureElectrical Grounding InstructionsEMI Information EMI InformationEMI Information Inspect/Adjust Safety INSPECTION/ TroubleshootingSafety Inspection Checklists Display Description Definition TroubleshootingTroubleshooting Electrical SUB Code Diagnostics CodePossible Solution E05 Symptom SolutionsJS REV TOO Large Symptom Probable Cause Solutions Troubleshooting CommonTroubleshooting Motor/Gearbox/Brake WheelsTion. Replace motor or gearbox if contamination Troubleshooting Battery Troubleshooting Battery ChargerChecking Battery Charge Level DON’TField Load Test Motor Testing Battery QualityInstalling Seat Seat AssemblyRemoving/Installing the Seat Assembly Removing SeatAdjusting the Seat Height Removing/Installing the Seat AssemblyVAN Seat with Hemi Front Rigging or Footboard Wheelchair Equipped with Available Mounting Holes forVAN Seat with NON-HEMI Front Rigging Removing/Installing the Adjustable Height Tubes Asba Seat with Footboard Or Front Riggings NON-HEMI or HemiRemoving/Installing the Adjustable Height Tubes Adjusting the Seat Width Adjustable Asba Seat Service ProceduresRemoving/Installing the Seat Pan Seat WidthAdjusting the Seat Depth Frame Size Seat Depth RangeSeat Depth DISTANCE* in Inches Removing/Installing Side Rails Adjusting the Seat DepthRemoving/Installing Side Rails Replacing the Seat Frame Replacing the Seat FrameRemoving/Installing the Back Canes Removing/Installing the Back Canes Replacing Seat Positioning StrapAdjusting the Back Angle 11 Adjusting the Back AngleAsba Seat Service Procedures 12 Removing/Installing the Seat PanChanging the Seat Width/Depth Replacing the Seat Frame 13 Replacing the Seat FrameReplacing the Seat Positioning Strap Back UpholsterySeat Assembly Seat Assembly 15 Removing/Installing the Back Upholstery Back Height16 Adjusting the Back Angle Angle Back Cane Mounting Hole Back Angle Plate HoleVan Seat Service Procedures Adjusting the Seat Position on Van Seat Frame18 Adjusting the Seat Position on Van Seat Frame Adjusting the Van Seat Back Depth Back Depth Seat SizeAdjusting Van Seat Arm Width Arm Service Procedures for Van SeatRemoving/Installing Van Seat Arm ArmsAdjusting Van Seat Arm Angle Adjusting Van Seat Arm HeightArmrest Pad Armrest Insert Mounting Screw Arm Post Washers Locknut Adjusting the Flip Back Armrest Arm Service Procedures for Asba or Adjustable Asba SeatRemoving/Installing Flip Back Armrest Adjusting the Flip Back Armrest Wheels Replacing the Front/Rear CastersAdjusting Caster Assembly Adjusting Caster AssemblyInstalling Removing/Installing the Front/Rear Caster AssembliesRemoving/Installing the Front Headtube Assembly RemovingRemoving the Drive Wheel Removing/Installing the Drive WheelInstalling the Drive Wheel Removing/Installing the Drive Wheel Inner Rim Installing/Removing Front Riggings Front RIGGINGS/ FootboardModel PH904A and PHAL4A Front Riggings Adjusting Footrest HeightModel PHWH93 Front Riggings Raising/Lowering Elevating Front Riggings Adjusting/Replacing Telescoping Front Rigging SupportsReplacing Heel Loops Van SeatStandard Position Inch OUT Inches OUT Adjustable Asba Seat Asba SeatRemoving/Installing the Footboard Assembly Depth Adjustment Angle/Depth/Height Adjustment of the Footboard AssemblyAngle Adjustment Height Adjustment 11 Depth Adjustment/Height AdjustmentRemoving/Installing the Shrouds SHROUDS/FRAMERemoving/Installing the Shrouds Disassembling/Reassembling the Side Frame Assembly Removing/Installing the Pivot TubeDisassembling/Reassembling the Side Frame Assembly Removing/Installing the SureStep Springs Removing/Installing the SureStep Springs Removing/Installing the Motor MotorsRemoving/Installing the Motor Release Lever Removing/Installing the Motor Release LeverReplacing Internal Motor Brushes Replacing Internal Motor Brushes Inspecting/Replacing External Motor Brushes Electro-Mechanical Parking Brake Testing Electro-Mechanical Parking Brake TestingBATTERIES/CHARGER Using the Proper Batteries Using the Proper BatteriesRemoving/Installing Batteries From/Into Battery Tray Tool Quantity CommentsInstalling Batteries Removing BatteriesRemoving/Installing Batteries From/Into Battery Tray Connecting/Disconnecting Battery Cables Connecting Battery Cables20 x 7/8-Inch Disconnecting Battery Cables Removed for clarityReplacing the On-Board Battery Charger Fuse Replacing the On-Board Battery Charger Replacing the On-Board Battery Charger FuseReplacing the On-Board Battery Charger Connecting Disconnecting/Connecting the JoystickDisconnecting Controller and JoystickRemoving/Installing the Joystick Van Seat ModelsAsba and Adjustable Asba Models Removing/Installing the Joystick Van Seat ModelsReplacing the Mkiv RII Controller Replacing the Mkiv RII Controller Replacing the MK5-NX or MK660 ACC Controller Replacing the MK5-NX or MK660 ACC ControllerDisassembling the Wheelchair DISASSEMBLING/ Assembling the M71Disassembling/Assembling the Wheelchair 104 Disassembling the Wheelchair Assembling the Wheelchair Assembling the Wheelchair Final Assembly Transport Ready Package About Transport Ready Packages SpecificationsModel Wheelchair Weight Limit Compliance InformationSecuring the Wheelchair to the Vehicle Positioning the Wheelchair in the VehicleSecurement Points Securing the WheelchairSecuring the Occupant Wheelchair-Anchored BeltsRating Description Vehicle-Anchored BeltsSeating System Positioning Belts Positioning BeltsLimited Warranty USA

Related manuals

Manual 28 pages 55.84 Kb